Periodic Service Schedules - Club Car 2012 Owner's Manual

PERIODIC SERVICE SCHEDULES

WARNING
• Service, repairs, and adjustments must be made per instructions in the maintenance and service
manual.
NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive maintenance
procedure should be performed more often than recommended in the periodic service and lubrication
schedules.
Both the Periodic Service Schedule and Periodic Lubrication Schedule must be followed to keep vehicle in
optimum operating condition.
PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES
REGULAR INTERVAL
Daily service by owner
Weekly service by owner
Monthly service by owner or trained
technician
Initial (one-time) inspection by owner or
trained technician after six weeks of use
SERVICE
Pre-Operation and Daily Safety Checklist
Performance Inspection
Batteries
Batteries (For vehicles NOT equipped with the
Single-Point Watering System)
Batteries (For vehicles equipped with the
Single-Point Watering System). Water monthly
or according to the established watering
interval.
Batteries
Tires
General vehicles
Batteries (For vehicles newly equipped with
the Single Point Watering System)
2012 through 2014 Precedent Golf Car Owner's Manual
Periodic Service Schedules
See Pre-Operation and Daily Safety
Checklist on page 28.
See Performance Inspection on page 28.
Charge batteries (after each daily use only).
Check electrolyte level. Add water if
necessary. See Battery Care – Vehicles
Without the Single-Point Watering System
on page 48.
Water the batteries. Observe that water flow
occurs and no water overflows from any cell.
See Battery Care – Vehicles Equipped with
the Single-Point Watering System on page
47.
Wash battery tops and clean terminals with
baking soda/water solution. Apply Battery
Terminal Protector Spray (CC P/N 1014305) to
battery terminals.
Check air pressure and adjust if necessary.
See Vehicle Specifications on page 63.
Thoroughly wash vehicle including the
underside.
For vehicles newly equipped with the SPWS,
manually check battery electrolyte levels of
all cells to verify correct valve operation. See
page 45.
Page 39