Fuel Lines; Fuel Shut-Off Valve - Club Car Turf 252 2007 Maintenance And Service Manual

18

Fuel Lines

FUEL LINES
See General Warning on page 1-1.
The fuel lines must be properly routed, and all hose clamps must be tight. The fuel lines should be kept clean.
See following WARNING.
WARNING
• Make sure fuel lines are the right length and are properly routed. Failure to heed this warning could
result in damage to fuel lines and fire.
Fuel line no. 1 runs directly from the fuel tank to the fuel filter (17). The fuel filter (17) has an arrow indicating fuel
flow direction (Figure 18-13, Page 18-18).
Fuel line no. 2 runs directly from the fuel filter to the fuel inlet of the fuel pump.
Fuel line no. 3 runs directly from the fuel outlet of the fuel pump to the carburetor.
Small spring steel band clamps are used on all hose connections except at the carburetor. A screw band clamp (21)
should be used at the carburetor.

FUEL SHUT-OFF VALVE

See General Warning on page 1-1.
The fuel shut-off valve is located on top of the fuel tank (Figure 18-18, Page 18-26 or Figure 18-19, Page 18-26). The
fuel shut-off valve should always be turned to the closed (OFF) position during vehicle storage, towing or trailering.
Unless the engine will be run as part of a procedure, the fuel shut-off valve should also be closed (OFF) before
performing maintenance or service procedures.
3
1. Fuel Shut-off Valve 2. Closed (OFF) 3. Open (ON) NOTE: When
selecting valve position, ensure that it is fully opened or fully closed.
449
Figure 18-18 Fuel Shut-off Valve – 49-State Fuel Tank
Page 18-26 2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual
3
1
2
1. Fuel Shut-off Valve 2. Closed (OFF) 3. Open (ON) NOTE: When
selecting valve position, ensure that it is fully opened or fully closed.
450
Figure 18-19 Fuel Shut-off Valve – California Fuel Tank
S27 FE 350 FUEL SYSTEM
1