Inspection Items At Least Once A Year - Geely EC718 2009 Workshop Manual

1-12 Vehicle Inspection
Brake Master Cylinder Fluid Level
Inspect the brake fluid level and maintain the correct fluid level.
If the fluid level is too low, it indicates that the brake pads have
been worn and need repair. Inspect the vent lid to ensure that
no dirt and air path blockage.
Clutch Pedal Free Travel
Inspect the clutch pedal free travel. Adjust if necessary. Without
the clutch pedal being pressed, measure the distance between
the clutch pedal center and the floor. Then, press the clutch
pedal all the way and measure the distance between the pedal
center and the floor. The difference between the two
measurements must be greater than 130 mm (5.19 in).
Doors and Windows Seals Lubrication
With a clean cloth to apply a layer of silicon grease coated film.
1.2.1.5 Inspection Items When Changing
Engine Oil
Manual Transmission Drive Axle
Inspect transmission fluid. Add transmission fluid if necessary.
3.3.8.1 Transmission Fluid Level
Brake System
Special attention: Low brake fluid level may indicate that disc
brake pads have been worn and need repair. In addition, if the
brake system warning lamp is always on, the brake system may
be faulty. If the anti-lock brake system warning lamp is always
on, the anti-lock braking system may be faulty. Inspect the ABS
system when wheel removal and rotation is carried out. Inspect
the pipe and hose connections are correct, and whether there
are catching, leakage, cracks, or scratches. Inspect for the disc
brake pads worn. Inspect brake disc surface conditions at the
same time inspecting other brake system components,
including brake wheel cylinders, park brake etc. Inspect the
park brake adjustment. If the driving habits and driving
conditions require frequent braking, brake inspection interval
should be shortened.
Steering Systems, Suspension and Front Drive Axle
Shields and Seals
Inspect front and rear suspension and steering system for
component damage, loose or missing. Inspect for signs of wear
or lack of lubrication. Inspect whether power steering system,
pipe and hose is connected properly, and whether there are
catching, leakage, cracks, or scratches. Clean the drive axle
jacket and seals and inspect for damage, cracking or leakage,
if necessary, replace the seals.
EC718/EC718RV EC715/EC715RV 10/2009
Inspection.
Exhaust System
Inspect the entire exhaust system, including the catalytic
converter. Inspect vehicle body near the exhaust system, to
refer to whether there are parts broken, damaged, missing or
misaligned. Inspect whether there are cracks, holes or loose
connections. Inspect other causes for poor floor heat
ventilation. Inspect the cause for exhaust heat entering into the
luggage compartment or passenger compartment.
Throttle Linkage
Inspect the throttle linkage to refer to whether there are scratch,
parts damaged or missing. Apply the appropriate grease
lubrication at all joints, the middle throttle shaft bearings,
throttle valve assembly spring on the accelerator pedal and the
pedal surface. Inspect for throttle linkage free movement.
Engine Drive Belt
Inspect the drive belt for cracking, wear and proper tension. If
necessary, adjust or replace the drive belt.
Hood Locking Latch Operation
Open the hood. Observe the operation of auxiliary locking
latch. when the main lock latch is released, the auxiliary locking
latch should be able to prevent the hood fully open. The hood
must be able to fully closed.

1.2.1.6 Inspection Items At Least Once A Year

The Condition and Operation Of Seat Belts
Inspect seat belt system, including the woven belt, buckle,
release button, retractor, guide ring and fixtures.
Spare Tire and Jack Storage
Be aware of the rattle sound from the rear of vehicle. Spare tire,
all the jacking equipment and tools must always be well fixed.
Each time after use, lubricate ratchet jack or screw mechanism
with the engine oil .
Key Lock Maintenance
Lubricate key cylinder.
Body Lubrication
Lubricate all door hinges, including the hood, the fuel filler door,
luggage compartment (hatchback) hinges and locking latch,
glove box, console door and any folding seat parts.
Vehicle Overview