Body (Interior And Exterior) Troubleshooting - Hyundai Tiburon 2003 Workshop Manual

TIBURON(GK) > 2003 > G 2.7 V6 DOHC > Body (Interior and Exterior) > General Information >
Troubleshooting, TIBURON(GK) > 2003 > G 2.7 V6 DOHC > Body (Interior and Exterior) > General
Information > Troubleshooting
TROUBLESHOOTING
Trouble symptom
Water leaks from sunroof
Wind noise around sunroof
Sunroof makes a noise when
moved
Motor runs but sunroof does not
move or moves only halfway
Noise in motor (clutch slipping
noise from motor when sunroof
is fully opened or closed is not
an unusual noise.)
Door glass fails to operate up
and down
Door does not open or close
completely
Hood does not open or close
completely
Water leak through windshield
and rear window
Wind noise around door
http://www.hmaservice.com/viewer/content.asp?IsPrint=true&imgnum=1&print_title...
Probable cause
Dirt accumulated in drain tube
Clogged drain tube
Broken or dislocated drain tube, defective
or cracked clip
Deteriorated roof lid weatherstrip
Excessive roof lid-to-body clearance and
improperly fitted weatherstrip
Loose or deformed deflector, gaps in body
work
Foreign particles lodged in guide rail
Loose guide rails and lid
Foreign particles lodged in guide rail
Incorrect engagement of motor pinion with
drive cable
Decrease in motor's clutch slipping force
Increased sunroof sliding resistance or
interference of sunroof with drive cables,
weatherstrip, etc. due to maladjustment of
sunroof
Incorrect engagement of motor pinion with
drive cable
Worn out or damaged motor pinion bearing Replace motor assembly
Worn out or deformed drive cable
Incorrect window glass installation
Damaged or faulty regulator arm or
regulator
Incorrect door installation
Defective door check assembly
Door hinge requires grease
Striker and latch not properly aligned
Incorrectly installed hood
Incorrect hood bumper height
Defective seal
Defective flange
Weatherstrip not holding firmly
Improperly installed weatherstrip
Improperly closed door
Page 1 of 2
Remedy
Clear dirt inside of drain
Blow air into drain to remove dirt
Check tube installation and
flange contact
Replace
Adjust
Retighten adjust or replace
Check drive cable and guide
rails for foreign particles
Retighten
Check drive cable and guide
rails for foreign particles
Check for loose motor
installation and damaged pinion
Adjust
Adjust or replace
Check pinion installation and
retighten motor
Replace
Adjust position
Correct or replace
Adjust position
Correct or replace
Apply grease
Adjust
Adjust
Adjust
Fill with sealant
Correct
Adjust fit of door
Repair or replace
Adjust
24.04.2008