Air Bleeding - Hyundai Tiburon 2003 Workshop Manual

3. Connect a vinyl hose to the disconnected return hose, and drain the oil into a container.
4. Disconnect the high-tension cable at the ignition coil side.
While operating the starter motor intermittently, turn the steering wheel all the way to the left and then to the
right several times to drain the fluid.
5. Connect the return hose and fix it with a clip securely.
6. Fill the power steering fluid reservoir with the specified fluid.
PSF-3 : 0.75~0.8 lit.
7. Start the engine.
8. Check for fluid leaks from the hose, then stop the engine.
9. Pour the fluid into the bottom of the oil filter in the power steering fluid reservoir.
10. Bleed the air.

AIR BLEEDING

1. Disconnect the ignition coil high tension cable, and then, while operating the starter motor intermittently (for 15
to 20 seconds), turn the steering wheel all the way to the left and then to the right five or six times.
1. During air bleeding, replenish with the fluid so that the level does not fall below the lower position of
the filter.
2. If air bleeding is done while the vehicle is idling, the air will be broken up and absorbed into the fluid.
Be sure to do the bleeding only while cranking.
2. Connect the high tension cable, and then start the engine (idling).
3. Turn the steering wheel to the left and then to the right, until there are no air bubbles in the oil reservoir.
4. Confirm that the fluid is not milky and that the level is between "MAX" and "MIN" marks on the reservoir.
5. Check that there is a little change in the fluid level when the steering wheel is turned left and right.
1. If the fluid level varies 5mm (0.2 in.) or more, bleed the system again.
2. If the fluid level suddenly rises after stopping the engine, further bleeding is required.
3. Incomplete bleeding will produce a chattering sound in the pump and noise in the flow control valve,
and lead to decreased durability of the pump.
http://www.hmaservice.com/viewer/content.asp?IsPrint=true&imgnum=1&print_title...
Page 5 of 7
24.04.2008