SELVA MARINE Pike 9,9 Service Manual page 289

A.
Abbreviation ................................................1-3
Adjusting the pilot screw ...........................4-13
Adjusting the throttle cable (H model).........3-7
Adjusting the throttle cable (R model).........3-8
Adjusting the throttle link.............................3-9
After test run .............................................1-19
Assembling the carburetor ........................4-12
Assembling the cylinder block...................5-48
Assembling the cylinder head ...................5-35
Assembling the drive shaft
housing ......................................... 6-13
Assembling the friction plate .....................7-12
Assembling the fuel pump...........................4-6
Assembling the gear pump .......................7-45
Assembling the lower case ............. 6-12
Assembling the manual starter ...................5-9
Assembling the propeller shaft
assembly......................................... 6-8
Assembling the propeller shaft
housing ........................................... 6-9
Assembling the PT motor..........................7-39
Assembling the starter motor ....................8-25
Assembling the swivel bracket..................7-29
Assembling the tilt cylinder .......................7-50
Assembling the upper case.......................7-22
B.
Backlash ...................................................6-17
Backlash (high thrust model) ....................6-42
Bleeding the PT unit..................................7-52
Bottom cowling..........................................7-14
Bow view.....................................................8-9
Bracket unit ...............................................3-12
Break-in.....................................................1-19
C.
Carburetor...................................................4-9
Carburetor unit ............................................4-7
Changing the engine oil ..............................3-4
Changing the gear oil................................3-14
Charging system (E model) ......................8-36
Checking the anode ..................................3-16
Checking the battery .................................3-16
Checking the battery (E model) ................1-14
Checking the bearing ...................... 6-12
Checking the brush holder and
brush ............................................. 7-39
Checking the camshaft .............................5-35
Checking the carburetor............................4-11
Checking the CDI unit ...............................8-34
Checking the charge coil...........................8-32
6AU3K11
Checking the choke solenoid (R model)... 8-36
Checking the compression pressure .......... 5-1
Checking the connecting rod big end
side clearance ........................................ 5-45
Checking the connecting rod small end
inside diameter and big end inside
diameter.................................................. 5-44
Checking the cooling water passage.......... 3-7
Checking the cooling water pilot hole ....... 1-19
Checking the crankpin oil clearance......... 5-45
Checking the crankshaft ........................... 5-45
Checking the crankshaft journal oil
,
6-34
clearance ................................................ 5-46
Checking the cylinder bore ....................... 5-42
Checking the cylinder head ...................... 5-29
Checking the diaphragm and valve ............ 4-5
,
6-33
Checking the drive shaft ..................6-12
Checking the electrical component........... 8-19
Checking the engine idle speed ............... 3-11
,
6-28
Checking the engine oil .............................. 3-4
Checking the engine oil level.................... 1-13
,
6-29
Checking the engine shut-off switch
(H model)................................................ 8-33
Checking the engine shut-off switch
(R model)................................................ 8-33
Checking the engine start button
(H model with electric starter)................. 8-26
Checking the engine start button or
switch and engine shut-off switch........... 1-17
Checking the engine start switch
(R model)................................................ 8-27
Checking the exhaust manifold, oil pan,
and exhaust guide .................................. 7-22
Checking the filter..................................... 7-44
Checking the fuel filter .........................3-3
Checking the fuel joint ................................ 4-5
Checking the fuel joint and fuel hose
(fuel joint-to-carburetor) ............................ 3-3
Checking the fuel pump.............................. 4-4
Checking the fuel system ......................... 1-13
Checking the fuse..................................... 7-54
Checking the fuse (E model) .................... 8-26
Checking the gear oil................................ 3-14
Checking the gear oil level ....................... 1-14
Checking the gear pump .......................... 7-44
Checking the gear shift and throttle
operation................................................. 1-15
,
6-33
Checking the gear shift operation
(H model)................................................ 3-10
,
8-24
Checking the gear shift operation
(R model)................................................ 3-10
Checking the ignition coil.......................... 8-31
Checking the ignition spark ...................... 8-30
Index
1
2
3
,
6-33
4
5
6
,
4-4
7
8
9
i-1