BR
HEATING AND AIR CONDITIONING
24 - 27
A/C CONDENSER
Fig. 19 Defrost Duct
A/C CONDENSER
J9424-35
Fig, 20 A/C Condenser Mounting—Typical
Gasoline
Engine
R E M O V A L
(1) Disconnect the negative cable from the battery.
(2) Recover the refrigerant into a recovery/recycle
device (refer to Refrigerant Service Procedures).
(3) Disconnect the quick-connect fittings at the
condenser.
(4) Remove the fixed orifice tube using a needle
nose pliers.
INSTALLATION
(1) Install the fixed orifice tube.
(2) Connect the quick-connect fittings at the con
denser.
(3) Evacuate and charge the A/C system (refer to
Refrigerant Service Procedures).
(4) Connect the negative cable to the battery.
J9424-36
Fig. 21 A/C Condenser Mounting—Diesel Engine
HIGH PRESSURE CUT-OUT SWITCH
The high pressure cut-out switch is located on the
discharge line near the compressor.
REMOVAL
(1) Disconnect the negative cable from the battery.
(2) Remove the connector from the switch.
(3) Unscrew the switch (Fig. 25).
INSTALLATION
'
(1) Install and tighten the switch.
(2) Install the connector onto the switch.
(3) Connect the negative cable to the battery.
VACUUM RESERVOIR
The vacuum reservoir is located under the battery
tray.