Dodge RAM TRUCK 1500 1995 Service Manual page 1741

i
r f
v. script\Qn
^ r o B i p = F a g @ D e s c r i p t i o n
Group-Page Description
Group-Page
PINION REMOVAL/DISASSEMBLY; REAR
SUSPENSION AND A X L E . . . . . . . . . . . . . . . . 3-31
PINION SEAL REPLACEMENT; FRONT
SUSPENSION AND AXLE 2-23
PINION SEAL REPLACEMENT; REAR
SUSPENSION AND A X L E . . . . . . . . . . . . . . . . 3-13
PINION SEAL REPLACEMENT—MODEL
80 3-27
PINION SEAL REPLACEMENT—MODEL
70 AND 8 0 . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-27
PINS #15 AND #18—PCM OUTPUT,
INTAKE MANIFOLD AIR HEATER
R E L A Y S — P C M 14-91
PINS #27 AND #28—PCM INPUT, AIR
CONDITIONING (A/C) CONTROLS—
P C M , . . . . . . . . I . . . . . . . . . . . . . . . . . 14-41
PINS #33 AND #53—PCM OUTPUT,
SPEED CONTROL—PCM 14-42,14-95
PINS #48, #49 AND #50—PCM INPUT,
SPEED CONTROL—PCM . . . . . . . . . . 14-41,14-97
PINS #53 AND #33—PCM OUTPUT,
SPEED CONTROL—PCM 14-47,14-97
PIPE, EXHAUST .11-14,11-5
PISTON AND CONNECTING ROD
ASSEMBLY . . . . . . . 9-101,9-138,9-171,9-40,9-88
PISTON AND RETAINER SERVICE,
OVERDRIVE .21-214
PISTON AND W O R M SHAFT
REPLACEMENT, RACK 19-30
PISTON RETAINER INSPECTION AND
OVERHAUL, OVERRUNNING
CLUTCH—LOW-REVERSE D R U M —
OVERDRIVE . . . 2 1 - 1 6 6
PITMAN SHAFT AND SIDE COVER
REPLACEMENT. 19-26
PITMAN SHAFT SEALS AND BEARING
REPLACEMENT 19-32
PITMAN SHAFT S E A L S — I N CAR
REPLACEMENT . . ,19-20
PIVOT BEARINGS, FRONT AXLE U-JOINT . . . 0-33
PIVOT BRACKET, SNOW PLOW . . . . . . . . . . 13-18
PLANETARY GEAR TRAIN AND
INTERMEDIATE SHAFT OVERHAUL . . . . . . 21-176
PLANETARY GEARTRAIN OVERHAUL . . . . 21-226
PLASTIC COMPONENT INSPECTION,
R U B B E R . . . . . . . . . . . . . . . . . . . . . . . . 0-25,0-29
PLASTIC HOSES/TUBING, RUBBER . . . . . . . . 0-34
PLASTIGAGE, MEASURING WITH . . . . . . . . . . 9-3
PLATE, BODY CODE . . lntro.-2
PLATE INSTALLATION, BRAKE SUPPORT . . . 5-71
PLATE LAMP BULB, LICENSE 8L-12
PLATE LAMP PANEL, LICENSE . . . . . . . . . . 8L-12
PLATE L A M P S , TAIL LAMPS AND REAR
LICENSE 8W-51-1
PLATE REMOVAL, BRAKE SUPPORT . . . . . . . 5-71
PLATE SERVICE, CONVERTER AND
DRIVE ..21-154
PLATE, SKID . . . . . 1 3 - 2
PLATE, VEHICLE IDENTIFICATION
NUMBER (VIN) . . . . . . . . . . . . . . . . . . . . . lntro.-1
PLATE/SNAP RING SPECIFICATIONS,
SPACER/THRUST. .21-329
PLOW CONTROL MODULE, SNOW . . . . . . . 13-19
PLOW DIAGNOSIS, SNOW . . . . . . . . . . . . . 13-11
PLOW FRAME, SNOW . . . . . . . . . . . . . . . . . 13-18
PLOW MALFUNCTION DIAGNOSIS AND
TESTS, S N O W . . . . . . . . . . . . . . . 1 3 - 6
PLOW PIVOT BRACKET, SNOW . . . 1 3 - 1 8
PLOW, SNOW . . . . . . . . . . . . . . . . . . . . . . . . 1 3 - 5
PLOW SPECIFICATIONS, SNOW 13-21
PLOW WIRING DIAGRAMS, SNOW . . . . . . . . 13-6
PLUG A S S E M B L Y REPLACEMENT,
A D J U S T E R . . . . . . . . . . . . . . . . . . . . . . . . . . 19-27
PLUG CABLE ORDER—8.0L V-10
ENGINE, SPARK 8D-37
PLUG CABLE RESISTANCE, SPARK . 8D-20.8D-36
PLUG, HOUSING END . . . . . . . . . . . . . . . . . 19-26
PLUG LOCATIONS, DRAIN AND FILL .21-3
PLUG SECONDARY CABLES,
SPARK ...8D-19.8D-31
PLUGS, SPARK; IGNITION
S Y S T E M S 8D-17,8D-30,8D-36
PLUGS, SPARK; LUBRICATION AND
MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . 0-24
PLUNGER LIFT—AUTOMATIC
TRANSMISSION, FUEL INJECTION
PUMP 14-149
PLUNGER LIFT—MANUAL
TRANSMISSION, FUEL INJECTION
PUMP ....14-149
POLISHING, WET SANDING,BUFFING 23-43
POOR CONNECTIONS, INTERMITTENT . . 8W-01-4
POSITION SENSOR, CAMSHAFT; FUEL
SYSTEM 14-75
POSITION SENSOR, CAMSHAFT;
FUEL7IGNITION 8W-30-4
POSITION SENSOR, CRANKSHAFT; FUEL
SYSTEM.... 14-75
POSITION SENSOR, CRANKSHAFT;
FUEL/IGNITION 8W-30-4
POSITION SENSOR TEST, CAMSHAFT . . . . . 14-57
POSITION SENSOR TEST, CRANKSHAFT . . . 14-57
POSITION SENSOR TEST,
THROTTLE 14-114,14-61
POSITION SENSOR TEST—3.9L V-6 OR
5.2/5.9L V-8 ENGINES, CAMSHAFT . . . . . . . 8D-9
POSITION SENSOR TEST—3.9L V-6 OR
5.2/5.9L V-8 ENGINES, CRANKSHAFT..... 8D-10
POSITION SENSOR TEST—8.0L V-10
ENGINE, CAMSHAFT . . . . . . . . . . . . . . . . . . 8D-10
POSITION SENSOR TEST—8.0L V-10
ENGINE, CRANKSHAFT . . . . . . . . . . . . . . . . 8D-11
POSITION SENSOR, THROTTLE; FUEL
SYSTEM 14-145
POSITION SENSOR, THROTTLE;
FUEL/IGNITION 8W-30-4.8W-30-8
POSITION SENSOR (TPS), THROTTLE . . . . 14-84
POSITION SENSOR—3.9L V-6 OR
5.2/5.9L V-8 ENGINES, CAMSHAFT .. 8D-22.8D-2
POSITION SENSOR—3.9L V-6 OR
5.2/5.9L V-8 ENGINES,
CRANKSHAFT 8D-24.8D-3
POSITION SENSOR—8.0L V-10 ENGINE,
CAMSHAFT . . 8D-23.8D-3
POSITION SENSOR—8.0L V-10 ENGINE,
CRANKSHAFT 8D-25.8D-4
POSITION SENSOR—PCM PIN
#22—PCM INPUT, THROTTLE 14-39,14-93
POSITION SENSOR—PCM PIN
#24—PCM INPUT, CRANKSHAFT 14-41
POSITION SENSOR—PCM PIN
#44—PCM INPUT, CAMSHAFT 14-45
POSITION SWITCH, CLUTCH PEDAL 6-3
POSITION SWITCH, PARK/NEUTRAL;
FUEL/IGNITION 8W-30-5
POSITION SWITCH, PARK/NEUTRAL;
TRANSMISSION AND TRANSFER CASE .. 21-146
POSITIVE CRANKCASE VENTILATION
(PCV) SYSTEM 25-8
POWER ANGLING CYLINDER SERVICE ....13-18
POWER BOOSTER CHECK VALVE TEST 5-7
POWER BOOSTER VACUUM TEST 5-7
POWER BRAKE BOOSTER
IDENTIFICATION 5-16
POWER BRAKE BOOSTER INSTALLATION ..5-18
POWER BRAKE BOOSTER OPERATION 5-17
POWER BRAKE BOOSTER REMOVAL 5-17
POWER BRAKE BOOSTER
SERVICEABILITY .5-17
POWER BRAKE BOOSTER—BRAKE
PEDAL—BRAKELIGHT SWITCH 5-16
POWER BRAKE VACUUM PUMP (DIESEL
MODELS) 5-21
POWER (DEVICE) GROUND 8W-30-6
POWER DOOR LOCKS 8W-61-1
POWER GROUND—PCM PIN #11 . . . 14-36,14-90
POWER GROUND—PCM PIN #12 . . . 14-36,14-90
POWER LOCK MOTOR 8P-1,8P-2
POWER LOCK MOTOR AND LATCH
REMOVE/INSTALL . . . . . . . . . . . . . . . . . . . . . 8P-2
POWER LOCK SWITCH 8P-1
POWER LOCK SWITCH REMOVE/
INSTALL 8P-2
POWER MIRROR REMOVE/INSTALL . . . . . . . 8T-4
POWER MIRROR SWITCH 8T-1
POWER MIRROR SWITCH REMOVE/
INSTALL 8T-3
POWER MIRRORS 8T-1,8T-2,8W-62-1
POWER OUTLET 8W-41-1
POWER SEAT ADJUSTER/MOTORS . . . . . . . 8R-1
POWER SEAT ADJUSTER/MOTORS
REMOVE/INSTALL 8R-3
POWER SEAT CIRCUIT . . . . . . . . . . . . . . . . . 8R-3
POWER SEAT SWITCH 8R-1,8R-2
POWER SEAT SWITCH CONTINUITY 8R-2
POWER SEAT SWITCH REMOVE/INSTALL .. 8R-3
POWER STEERING GEAR,
RECIRCULATING BALL . . . . . . . . . . . . . . . . 19-20
POWER STEERING GEAR
SPECIFICATIONS 19-34
POWER STEERING HOSE . . . . . . . . . . . . . . 19-12
POWER STEERING PUMP . . . . . . . . . . . . . . 19-12
POWER STEERING PUMP—INITIAL
OPERATION 19-17
POWER STEERING SYSTEM . . . . . . . . . . . . . 0-35
POWER STEERING SYSTEM DIAGNOSIS . . . 19-3,
19-4,19-5,19-6,19-7,19-8,19-9
POWER UNIT ...13-15
POWER WINDOW MOTOR 8S-1,8S-2
POWER WINDOW MOTOR REMOVE/
INSTALL 8S-3
POWER WINDOW SWITCH .. 8S-1,8S-2
POWER WINDOW SWITCH REMOVE/
INSTALL 8S-3
POWER WINDOWS 8W-60-1
POWERED ENGINES, FUEL PRESSURE
LEAK DOWN TEST—GAS 14-6
POWERED ENGINES, FUEL PUMP
CAPACITY TEST—GAS ....14-6
POWERED ENGINES, FUEL PUMP
MODULE—ALL GAS 14-2
POWERED ENGINES, FUEL SYSTEM
PRESSURE TEST—GAS . . . . . . . . . . . . . . . . 14-5
POWERED ENGINES, FUEL SYSTEM
PRESSURES—GAS 14-149
POWERED ENGINES, TORQUE—GAS...... 14-148
POWERED VEHICLES, ON-BOARD
DIAGNOSTICS (OBD)—DIESEL . . . . . . . . . 14-115
POWERED VEHICLES, ON-BOARD
DIAGNOSTICS (OBD)—GAS 14-66
POWER-LOK MODEL 70 AXLE AND
TRAC-LOK MODEL 80 AXLE . . . . . . . . . . . . . 3-48
POWER—PCM PIN #6—PCM INPUT,
FIVE VOLT 14-36,14-90
POWER—PCM PIN #7—PCM INPUT,
EIGHT V O L T . . . . . . . . . . . . . . . . . . . . 14-36,14-90
POWERTRAIN CONTROL MODULE; FUEL
SYSTEM 14-19
POWERTRAIN CONTROL MODULE;
VEHICLE SPEED CONTROL SYSTEM .. 8H-1.8H-9
POWERTRAIN CONTROL MODULE
(PCM); EMISSION CONTROL SYSTEMS . . . 25-23
POWERTRAIN CONTROL MODULE
(PCM); FUEL SYSTEM 14-145,14-29,14-83
POWERTRAIN CONTROL MODULE
(PCM); IGNITION SYSTEMS... 8D-16,8D-29,8D-7
POWERTRAIN CONTROL MODULE (PCM)
60-WAY CONNECTOR 14-101,14-57
POWERTRAIN CONTROL MODULE
]PCMV-DIESEL 14-87
POWERTRAIN CONTROL MODULE
TESTING 14-113,14-65
PRE-ALIGNMENT INSPECTION IFS
SUSPENSION 2-6
PRE-ALIGNMENT INSPECTION LINK/COIL
SUSPENSION.. 2-4
PRECAUTIONS 16-10,16-3,16-8
PRECAUTIONS AND WARNINGS,
SAFETY; BODY COMPONENTS . . . . . . . . . . 23-24
PRECAUTIONS AND WARNINGS,
SAFETY; BUMPERS AND FRAME 13-22
PRECAUTIONS, BRAKE SAFETY .5-2
PRECAUTIONS, SAFETY . . . . . . . . . . . . . . . . 8L-1
PRECAUTIONS, SERVICE . . . . . . . . . . . . . . . . 24-5
PRECAUTIONS, WARNINGS, CAUTIONS
AND SERVICE 24-5
PRELIMINARY BRAKE CHECK 5-4
PRELIMINARY CHECKS 7-5
PRELIMINARY DIAGNOSIS 21-106
PREPARATION, HEADLAMP ALIGNMENT . . . 8L-6
PRESSURE CAP, RADIATOR 7-42
PRESSURE CUT-OUT SWITCH, HIGH . . . . . 24-27
PRESSURE DIAGNOSIS 24-10
PRESSURE, ENGINE OIL .9-7
PRESSURE GAUGE, OIL . . . . . . . . . . . . . 8W-40-1
PRESSURE GAUGES . . . . . . . . . . . . . . . . . . . 22-2
PRESSURE LEAK DOWN TEST—GAS
POWERED ENGINES, FUEL 14-6
PRESSURE LEAKAGE TEST, CYLINDER
COMBUSTION 9-6
PRESSURE (MAP) SENSOR, MANIFOLD
ABSOLUTE; FUEL SYSTEM 14-81