Maintenance And Lubrication - Isuzu 1999 RODEO Workshop Manual

RODEO
Maintenance Schedule List
Explanation of Complete Vehicle Maintenance
Schedule . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recommended Fluids and Lubricants
Maintenance Schedule List
Normal Vehicle Use
The maintenance instructions in this Maintenance
Schedule are based on the assumption that the vehicle
will be used as designed:
f to carry passengers and cargo within the limitations
specified on the tire placard located on the inside of
the glove compartment door;
f to be driven on reasonable road surfaces within legal
operating limits;
f to be driven on a daily basis, as a general rule, for at
least several miles/kilometers;
f to be driven on unleaded fuel
Unusual or severe operating conditions will require more
frequent vehicle maintenance, as specified in the
following sections.
CHANGE ENGINE OIL AND OIL FILTER
CHANGE AUTOMATIC TRANSMISSION FLUID
CHANGE REAR AXLE OIL
REPLACE TIMING BELT
REPLACE AIR CLEANER FILTER
CHANGE POWER STEERING FLUID
GENERAL INFORMATION

Maintenance and Lubrication

CONTENTS
. . . . . . . . . . . . . . . 0B-1
0B-5
. . . . 0B-8
ITEMS
MAINTENANCE AND LUBRICATION
Lubricant Viscosity Chart
Recommended Liquid Gasket
Recommended Thread Locking Agents
Maintenance Service Data
Severe Driving Conditions
If the vehicle is usually operated under any of the severe
driving conditions listed below, it is recommended that the
applicable maintenance services be performed at the
specified interval shown in the chart below.
Severe driving conditions:
f Towing a trailer, using a camper or car top carrier.
f Repeated short trips of less than 8 Km (5 miles) with
outside temperature remaining below freezing.
f Extensive idling and/or low speed driving for long
distances, such as police, taxi or door-to-door
delivery use.
f Operating on dusty, rough, muddy or salt spread
roads.
INTERVAL
Every 3,000 miles (4,800 km) or 3 months
Every 20,000 miles (32,000 km)
Every 15,000 miles (24,000 km)
Every 75,000 miles (120,000 km)
See explanation of service, page 0B-5
Every 30,000 miles (48,000 km)
SECTION
0B-1
. . . . . . . . . . . . . . . . . 0B-9
. . . . . . . . . . . 0B-11
. . . 0B-12
. . . . . . . . . . . . . . . . 0B-13