Detroit Diesel MBE 4000 Service Manual page 565

www.rtrucks.ru
Diesel engine exhaust and some of its constituents are
known to the State of California to cause cancer, birth
defects, and other reproductive harm.
2. Run the engine at moderate speed until the thermostat starts to open, at an operating
temperature of approximately 176 F (80 C). Then run it for about five minutes longer.
Shut down the engine and allow it to cool to approximately 112 F (50 C).
3. Drain all the cleaning solution.
4. Flush the cleaning solution from the cooling system.
[a] Immediately after draining the cleaning solution, flush the system with clean water.
[b] Once the clean water has drained, fill the system again with clean water.
[c] Run the engine. Allow the engine to warm up to approximately 176 F (80 C), and
then run it about five minutes longer.
[d] Drain the hot water.
5. Fill the cooling system with new coolant. For detailed procedures, see the vehicle/chassis
maintenance manual. For types of coolant,
14.1.4
Required protective measures for the MBE 4000 engine depend on the following:
The length of time that the engine will be out of service
The climate and conditions where the engine is stored
After cleaning, engines should, whenever possible, be placed in a dry, well-ventilated place.
In all cases, protect the engine against direct exposure to moisture (rain/splash water).
If the engine is to be out of service for 12 months or less, anticorrosion measures are not
necessary, provided that the place of storage are dry and well-ventilated as described above.
All information subject to change without notice.
6SE412 0403 Copyright © 2004 DETROIT DIESEL CORPORATION
www.rtrucks.ru
PERSONAL INJURY
Always start and operate an engine in a well ventilated
area.
If operating an engine in an enclosed area, vent the
exhaust to the outside.
Do not modify or tamper with the exhaust system or
emission control system.
Storage
www.rtrucks.ru
www.rtrucks.ru
MBE 4000 SERVICE MANUAL
www.rtrucks.ru
14-5
www.rtrucks.ru