Ford Transit 2002 Owner's Manual page 1429

Fuel Tank and Lines - Fuel Supply Line—
1.8L Duratorq-TDCi (Lynx) Diesel/1.8L
Duratorq-TDDi (Lynx) Diesel
Removal and Installation
Special Tool(s)
Alignment Pins, Subframe
205-316 (15-097A)
General Equipment
Transmission jack
WARNINGS:
Do not smoke or carry lighted tobacco or open flame of any type when working on or
near any fuel related components. Highly flammable vapors are always present and may
ignite. Failure to follow these instructions may result in personal injury.
This procedure involves fuel handling. Be prepared for fuel spillage at all times and
always observe fuel handling precautions. Failure to follow these instructions may result
in personal injury.
Diesel fuel injection equipment is manufactured to very precise tolerances and
clearances. It is therefore essential that absolute cleanliness is observed when working
with these components. Always fit blanking plugs to any open orifices or lines.
Transit/Tourneo Connect 2002.5 (06/2002-)
1. Disconnect the battery ground cable. For
additional information, refer to Section
Battery, Mounting and
NOTE: Make sure the road wheels are in the
2.
straight ahead position.
Centralize the steering wheel.
3. Disconnect the steering column shaft from the
steering gear pinion extension.
Discard the bolt.
4. Raise and support the vehicle. For additional
information, refer to Section
Lifting.
5. Install the crossmember alignment pins.
http://vnx.su
Print
414-01
Cables.
100- 02 Jacking and