Ford Transit 2002 Owner's Manual page 1342

Fuel System - General Information - Fuel
System—1.8L Duratorq- TDCi (Lynx) Diesel
(75 PS/90 PS/110 PS), Vehicles Built
From: 08/2006
Diagnosis and Testing
Special Tool(s)
Hand Pressure Pump with Adapter Kit
310-110
General Equipment
Worldwide Diagnostic System (WDS)
Inspection and Verification
1. 1. Verify the customer concern.
2. 2. Visually inspect for obvious signs of mechanical or electrical damage.
Visual Inspection Chart
Mechanical
Fuel leak(s)
Fuel line(s)
Fuel filler cap
Fuel tank ventilation hose
Fuel tank filler hose
3. 3. If an obvious cause for an observed or reported concern is found, correct the cause
(if possible) before proceeding to the next step.
4. 4. If the cause is not visually evident, verify the symptom and refer to the Symptom
Chart.
Symptom Chart
Symptom
Engine cranks but * Fuel charging and
does not start controls.
* Air ingress into the
fuel lines.
* Contaminated fuel.
Poor starting * Fuel charging and
controls.
Fuel level
Fuel filter
Fuel tank
Possible Sources
*
*
*
*
http://vnx.su
Transit/Tourneo Connect 2002.5 (06/2002-)
Electrical
Wiring harness
Electrical connector(s)
Fuel level sensor
Action
REFER to: Fuel Charging and Controls - 75
PS/90 PS/110 PS, Vehicles Built From: 08/2006
(303-04B Fuel Charging and Controls - 1.8L
Duratorq-TDCi (Lynx) Diesel/1.8L Duratorq-
TDDi (Lynx) Diesel, Diagnosis and Testing).
GO to Pinpoint Test A.
DRAIN and REFILL the fuel system with fresh
fuel. INSTALL a new fuel filter.
REFER to: Fuel Filter - 1.8L Duratorq-TDCi
(Lynx) Diesel (310-01A Fuel Tank and Lines,
Removal and Installation).
REFER to: Fuel Charging and Controls - 75
PS/90 PS/110 PS, Vehicles Built From: 08/2006
(303-04B Fuel Charging and Controls - 1.8L
Duratorq-TDCi (Lynx) Diesel/1.8L Duratorq-
Print