Ford Transit 2002 Owner's Manual page 1024

Fuel Charging and Controls - 1.8L
Duratec-DOHC (85kW/115PS) - Zetec,
Liquefied Petroleum Gas (LPG) - Fuel
Charging and Controls
Diagnosis and Testing
Special Tool(s)
Terminal Probe Kit
418-S035
General Equipment
Worldwide Diagnostic System (WDS) (418-
F224)
Inspection and Verification
WARNINGS:
Do not modify the system configuration or components, or install components not
specially designed for use with alternative fuels. Ford Motor Company Ltd has specially
designed the materials, components and system configuration for alternative fuel
vehicles, and each particular system is precisely calibrated for efficient operation. The use
of incorrect parts or materials can produce an untested configuration that could result in
fire, or cause engine damage. Failure to follow these instructions may result in personal
injury.
Fuel supply lines will remain pressurized after shutdown. When servicing fuel related
components, do not smoke or carry lighted tobacco or any open flame of any type.
Flammable gases may be present and ignite. Failure to follow these instructions may
result in personal injury.
The fuel tank must be evacuated prior to tank removal. Failure to follow this
instruction may result in personal injury.
Eye, hand and ear protection are required to be worn during depressurizing or
removal and installation of fuel system components. Failure to follow this instruction may
result in personal injury.
Always ground the vehicle and alternative fuel system. High pressure gas escaping
can cause static electricity buildup and subsequent sparking. Failure to follow this
instruction may result in personal injury.
Never attempt to tighten or adjust fittings while system is pressurized. Failure to
follow these instructions may result in personal injury.
All gas lines must be installed prior to reconnecting the battery. Failure to follow this
instruction may result in personal injury.
CAUTIONS:
If the alternative fuel system is being disconnected for an extended length of time,
cover all open hose fittings and electrical connections to avoid contamination.
The engine will always start using petrol regardless of what fuel type is currently
selected. If the vehicle is in LPG mode when starting the LPG indicator lamp will flash to
indicate it is running on petrol and then switch over to LPG after a short period of time.
Transit/Tourneo Connect 2002.5 (06/2002-)
http://vnx.su
Print