Ford Transit 2002 Owner's Manual page 1369

Fuel System - General Information - 1.8L
Duratec-DOHC (85kW/115PS) - Zetec,
Liquefied Petroleum Gas (LPG) - Fuel
System Leak Test
General Procedures
Special Tool(s)
Actuator Cable
310-090 (23-064)
WARNINGS:
Fuel supply lines will remain pressurized after shutdown. When servicing fuel related
components, do not smoke or carry lighted tobacco or any open flame of any type.
Flammable gases may be present and ignite. Failure to follow these instructions may
result in personal injury.
This procedure involves fuel handling. Be prepared for fuel spillage at all times and
always observe fuel handling precautions. Failure to follow these instructions may result
in personal injury.
Never attempt to tighten or adjust fittings while the system is pressurized. Failure to
follow this instruction may result in personal injury.
All gas lines must be installed prior to reconnecting the battery. Failure to follow this
instruction may result in personal injury.
The fuel lines must be evacuated before attempting any repairs. Failure to follow
these instructions may result in personal injury.
Transit/Tourneo Connect 2002.5 (06/2002-)
1. Raise and support the vehicle.
For additional information, refer to:
02 Jacking and Lifting, Description and
Operation).
2. Disconnect the fuel tank electrical connector.
3. Install the special tool wiring harness and
connect to a 12V supply.
4. Check for leaks over all of the unions with an
electronic leak detector. If a leak is detected
identify the exact union with a liquid leak
http://vnx.su
Print
Lifting (100-