Ford Transit 2002 Owner's Manual page 1070

Starting System - Starting System—
Vehicles Built Up To: 08/2006
Diagnosis and Testing
Refer to Wiring Diagrams Section 303-06, for schematic and connector
information.
Inspection and Verification
1. 1. Verify the customer concern.
2. 2. Visually inspect for obvious signs of electrical damage.
Visual Inspection Chart
3. 3. If an obvious cause for an observed or reported concern is found, correct the cause
(if possible) before proceeding to the next step.
4. 4. If the cause is not visually evident, verify the symptom and refer to the Symptom
Chart.
Symptom Chart
Symptom Chart
Symptom
The engine does not
crank/the relay does click
The engine does not
crank/the relay does not
click
The engine cranks slowly
Electrical
Fuse(s)
Wiring harness
Electrical connector(s)
Relay
Central junction box (CJB)
Battery junction box (BJB)
Switch(es)
Battery
Starter motor
Possible Sources
* Battery. *
* Relay. *
* Circuit(s). *
* Starter motor. *
* Battery. *
* Fuse(s). *
* Passive anti-theft *
system (PATS).
* Ignition switch. *
* Circuit(s).
* Battery. *
* Starter motor. *
* Circuit(s). *
http://vnx.su
Transit/Tourneo Connect 2002.5 (06/2002-)
Action
REFER to Section 414-00 Charging System -
General Information.
CARRY OUT the relay Component Test.
REFER to the wiring diagrams.
GO to Pinpoint Test A.
CARRY OUT the starter motor Component
Test using WDS.
REFER to Section 414-00 Charging System -
General Information.
INSTALL a new fuse as necessary. If the fuse
fails again check for short to ground.
REFER to Section 419-01A Anti-Theft -
Active / 419-01B Anti-Theft -
GO to Pinpoint Test B.
REFER to Section 414-00 Charging System -
General Information.
CARRY OUT the starter motor Component
Test using WDS.
GO to Pinpoint Test C.
Print
Passive.