Ford Transit 2002 Owner's Manual page 1336

Fuel System - General Information - Fuel
System—75 PS/90 PS
Diagnosis and Testing
Special Tool(s)
Hand Vacuum/Pressure Pump
416-D001 (23-036A)
Inspection and Verification
WARNINGS:
Do not smoke or carry lighted tobacco of any type when working on or near any fuel
related components. Highly flammable mixtures are always present and may ignite.
Failure to follow these instructions may result in personal injury.
This procedure involves fuel handling. Be prepared for fuel spillage at all times.
Failure to follow this instruction may result in personal injury.
Diesel fuel injection equipment is manufactured to very precise tolerances and fine
clearances. It is therefore essential that absolute cleanliness is observed when working
with these components. Always fit blanking plugs to any open orifices or lines.
1. 1. Verify the customer concern.
2. 2. Visually inspect for obvious signs of mechanical or electrical damage.
Visual Inspection Chart
Mechanical
Fuel level
Fuel leak(s)
Fuel line(s)
Fuel filler cap
Fuel filter
Fuel tank
Fuel tank ventilation
hose
Fuel tank filler hose
3. 3. If an obvious cause for an observed or reported concern is found, correct the cause
(if possible) before proceeding to the next step.
4. 4. If the cause is not visually evident, verify the symptom and refer to the Symptom
Chart.
Symptom Chart
Symptom Chart
Symptom
Engine cranks but *
does not start -
vehicles with diesel
engine
Inertia fuel shutoff (IFS) switch - all except vehicles with
Fuel level sensor - vehicles with diesel engine
Fuel pump module - all except vehicles with diesel engine
Possible Sources
Fuel charging and *
controls.
http://vnx.su
Transit/Tourneo Connect 2002.5 (06/2002-)
Electrical
Fuse(s)
Relay(s)
Wiring harness
Electrical connector(s)
diesel engine
Engine
Action
REFER to Section 303-04A Fuel Charging and
Controls / 303-04B Fuel Charging and
Controls / 303-04C Fuel Charging and Controls
- Turbocharger / 303-04D Fuel Charging and
Print