SELVA MARINE Grey Whale 200 EFI Service Manual page 392

Index
Checking the gear oil level.............. 1-22
Checking the gear pump...........................7-43
Checking the gear pump housing .............7-44
Checking the gear shift and
throttle operation .....................................1-24
Checking the gear shift operation .............3-12
Checking the high-pressure fuel pump .....4-29
Checking the high-pressure
fuel pump relay .......................................8-39
Checking the hydraulic pressure...............7-32
Checking the ignition coil input voltage.....8-18
Checking the ignition spark.......................8-18
Checking the intake air pressure sensor...8-21
Checking the intake air
temperature sensor.................................8-20
Checking the intake manifold....................4-10
Checking the knock sensor.......................8-25
Checking the lower case................. 6-15
Checking the lower unit for air leakage.....3-15
Checking the low-pressure fuel pump.......4-22
Checking the low-pressure fuel
pump and high-pressure fuel pump ........8-39
Checking the magnet switch .....................8-45
Checking the main relay and
electronic throttle valve relay ..................8-27
Checking the neutral switch ......................8-24
Checking the oil control valve ...................8-36
Checking the oil pan and
exhaust manifold.....................................7-16
Checking the oil pressure ...........................5-1
Checking the oil pressure sensor................5-2
Checking the oil pump ..............................5-73
Checking the oil strainer ...........................7-16
Checking the outboard
motor mounting height ............................1-23
Checking the pinion and forward gear ......6-15
Checking the pinion and reverse gear ......6-45
Checking the piston
clearance (reference)..............................5-62
Checking the piston diameter ...................5-62
Checking the piston pin.............................5-64
Checking the piston pin boss bore............5-63
Checking the piston ring ...........................5-62
Checking the piston ring
end gap (reference) ................................5-63
Checking the piston ring groove ...............5-63
Checking the piston ring side clearance ...5-63
Checking the pressure regulator.................4-7
Checking the propeller ..............................3-16
Checking the propeller shaft ............. 6-9
Checking the propeller
shaft housing................................... 6-9
Checking the PTT fluid level .....................3-13
i-2
,
3-14 Checking the PTT motor........................... 7-36
Checking the PTT operation..................... 3-13
Checking the PTT relay ............................ 7-58
Checking the PTT switch.......................... 7-59
Checking the PTT system ........................ 1-24
Checking the Rectifier Regulator.............. 8-51
Checking the remote control cable ........... 1-23
Checking the reservoir.............................. 7-44
Checking the shift cut switch .................... 8-23
Checking the spark plug ............................. 3-8
Checking the starter motor ....................... 8-47
Checking the starter motor operation ....... 8-44
Checking the starter motor pinion............. 8-45
Checking the starter relay......................... 8-41
Checking the stator coil ............................ 8-50
Checking the steering system .................. 1-24
Checking the thermostat............................. 3-9
,
6-45 Checking the thermoswitch ...................... 8-22
Checking the throttle valve operation ....... 8-26
Checking the tilt cylinder and
trim cylinder ............................................ 7-51
Checking the timing belt ............................. 3-8
Checking the timing belt and sprocket...... 5-24
Checking the top cowling............................ 3-3
Checking the trim sensor.......................... 7-60
Checking the valve ..........................5-46
Checking the valve clearance..................... 5-9
Checking the valve guide ......................... 5-47
Checking the valve lifter ........................... 5-24
Checking the valve seat ........................... 5-49
Checking the valve spring ........................ 5-46
Checking the vapor separator .................. 4-29
Checking the vapor shut-off valve ............ 8-40
Checking the water detection switch ........ 8-37
Checking the water pump
and shift rod.....................................6-5
Checking using the YDIS............................ 8-1
Clamp bracket and swivel bracket............ 7-22
Connecting the communication
cable to the outboard motor...................... 9-5
Control system.......................................... 3-11
Cooling water hose..................................... 4-3
Crankcase ................................................ 5-57
Cylinder block ..................................5-57
Cylinder head ........................................... 5-43
D.
Dimension................................................. 2-12
Disassembling the bottom cowling ............. 7-5
,
6-39
Disassembling the cylinder block ............. 5-61
Disassembling the drive
,
6-38
shaft housing .................................6-14
Disassembling the forward gear ............... 6-14
,
7-51
,
6-34
,
5-59
,
6-44
6AL3J11