Recommended Fluids And Lubricants - Isuzu 2000 Trooper Workshop Manual

MAINTENANCE AND LUBRICATION
0B–8

Recommended Fluids and Lubricants

Engine
Engine coolant
Brake system
Power steering system
Automatic transmission
Manual transmission
Rear axle and front axle
Clutch system
a. Pivot points
b. Clutch fork joint
c. Master cylinder
Hood latch assembly
a. Pivots and spring anchor
b. Release pawl
Hood and door hinges
Chassis lubrication
Parking brake cables
Front wheel bearings
Shift on the fly system
Transfer Case (Except TOD and 2WD model)
TOD system
Extension assembly
Propeller shafts (Except TOD model)
Sliding yoke and Univeral joint
Body door hinge pins and linkage, fuel door hinge, rear
compartment lid hinges
Windshield washer solvent
Key lock cylinder
Accelerator linkage
USAGE FLUID/LUBRICANT
API SE, SF, SG, SH or ILSAC GF-1 Engine oil (See oil
chart on the following page for proper viscosity)
Mixture of water and good quality ethylene glycol base
type antifreeze.
DOT-3 hydraulic brake fluid.
DEXRON -III Automatic transmission fluid.
DEXRON -III Automatic transmission fluid.
Engine oil
(See oil chart on following page for proper viscosity)
GL-5 gear lubricant (Standard differential)
GL-5 Limited slip differential gear lubricant together with
limited slip differential lubricant additive (Part No.
8-01052-358-0) or equivalent (If equipped with optional
limited slip diferential) (See oil chart in this section for
proper viscosity)
Engine oil
Chassis grease
DOT-3 hydraulic brake fluid
Engine oil
Chassis grease
Engine oil
Chassis grease
Chassis grease
Wheel bearing grease
GL-5 gear lubricant
SAE40 (Areas where ambient temperatures of 32°C
(90°F) and higher are regularly encountered.)
SAE5W–30SF (Other areas)
DEXRON -III Automatic transmission fluid.
DEXRON -III Automatic transmission fluid.
Grease containing MoS or multipurpose type grease
2
NLGI No.2
Engine oil
Washer fluid
Synthetic light weight engine oil (SAE 5W-30)
Chassis grease