Suzuki GA413 Service Manual page 129

STEERING WHEEL AND COLUMN
WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System:
D Service on and around the air bag system components or wiring must be performed only by
an authorized SUZUKI dealer. Please observe all WARNINGS and SERVICE PRECAUTIONS
of ON-VEHICLE SERVICE in air bag system section before performing service on or around
the air bag system components or wiring. Failure to follow WARNINGS could result in
unintentional activation of the system or could render the system inoperative. Either of these
two conditions may result in severe injury.
D The procedures in this section must be followed in the order listed to temporarily disable the
air bag system and prevent false diagnostic codes from setting. Failure to follow procedures
could result in possible air bag system activation, personal injury or otherwise unneeded air
bag system repairs.
CAUTION:
When fasteners are removed, always reinstall them at the same location from which they were
removed. If a fastener needs to be replaced, use the correct part number fastener for that ap-
plication. If the correct part number fastener is not available, a fastener of equal size and
strength (or stronger) may be used. Fasteners that are not reused, and those requiring thread-
locking compound, will be called out. The correct torque value must be used when installing
fasteners that require it. If the above procedures are not followed, parts or system damage
could result.
GENERAL DESCRIPTION
Components . . . . . . . . . . . . . . . . . . . . . . . . . . .
DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection and Repair Required After
Accident . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE
Service precaution
(for vehicle with air bag system)
Service and diagnosis
Disabling air bag system
Enabling air bag system
Handling and storage
Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver air bag (inflator) module
(for vehicle with air bag system)
SECTION 3C
. . . . . . . . . . . . . . . . . 3C- 2
3C- 2
3C- 3
3C- 3
. . . . . . . . . . . . . . . . . . . 3C- 3
. . . . . . . . . 3C- 3
. . . . . . . . . . . . . . . . . 3C- 3
. . . . . . . . . . . . . . . 3C- 3
. . . . . . . . . . . . . . . 3C- 3
. . . . . . . . . . . . . . . . . 3C- 3
3C- 3
. . . . . . . . . 3C- 4
CONTENTS
Steering wheel
Centering contact coil (for vehicle with
air bag system)
Combination switch/contact coil and
combination switch assembly
Steering column assembly
Steering lock assembly (ignition switch)
Steering lower shaft
CHECKING STEERING COLUMN FOR
ACCIDENT DAMAGE
TIGHTENING TORQUE SPECIFICATIONS
REQUIRED SERVICE MATERIALS
SPECIAL TOOL
STEERING WHEEL AND COLUMN 3C-1
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
3C
3C- 6
3C- 8
3C- 8
3C-10
. . . . 3C-14
3C-15
3C-16
. . 3C-17
3C-17
3C-17