Accessories; Adjustment Procedures; Chain Linkage Adjustment; Brake Release Switch Adjustment - Pontiac Grand Prix Service Manual

CONTENTS OF THIS SECTION
SUBJECT PAGE SUBJECT PAGE
Cruise Control
. . .
.
. . .
. .
. . . . . .
.
.
15-1
Adjustment Procedures.
. . . . . . . . . . .
15- 1
Chain Linkage Adjustment
. .
.
. . . . . .
15-1
Release Switch Adjustment.
. . . . . . . .
15-1
Centering Spring Adjustment.
.
. . . . . .
15- 1
Minor Service.
. . . . . . . . . . . . . . . .
15-6
Cable and Gear Check.
.
. . . .
.
. .
.
. .
15-6
Major Service.
. . . . . . . . . . . . . . . .
15-6
Regulator Removal
. . .
. .
. . . . . . .
.
15-6
Regulator Overhaul
.
.
;
. . . . . . . . .
.15-7
Electric Clock.
. . . . . . .
.
. . . . . . . . .
15-9
Safeguard Speedometer
. . . . . .
.
. . . .
.
.
15-9
Rally Gages
. . . . . . . . . . . . . . . . . . .
15-10
Hood Mounted Tachometer
. .
.
. . . . . . . .
15-12
Deck Lid Release
. .
.
. . . . . . . . . . .
.
.
15-13
Vacuum Door Locks
. . .
. .
. . . . . . . . .
15-14
Vacuum Tire Pump.
. . . . . . . . . .
.
. . .
15-15
Rear Wheel Opening Cover
. . . . . . . . . .
15-16
ADJUSTMENT PROCEDURES
CHAIN LINKAGE ADJUSTMENT
1. Start engine and set carburetor to hot idle position.
2.
Thread bead chain thru hole in carburetor lever
extension (Fig. 15-2).
3. Adjust bead chain (at extension) to provide
minimum chain slack and assemble clip to extension
by straddling extension.
4. A minimum of two beads must extend outside of
clip after adjustment of chain and installation of clip.
Cut off exass chain.
BRAKE RELEASE SWITCH ADJUSTMENT (Fig. 153)
Apply brake pedal and push both switches forward as
far as possible. Pull pedal forcibly rearward to adjust
switches.
CENTERING SPRING ADJUSTMENT (Fig. 151)
1. If' Cruise Control holds speed three or more mph
Accessory Switch Cutouts
. . . . . . . .
.
. .
15-16
Rear Window Defogger
. . . . . . . . . . . . .
15-17
Heated Rear Window
. . . .
. . . . .
.
.
. . .
15-18
Cornering Lamps
. . . . . . . . . . . . . . . .
15-20
Underhood Lamp
. . . . . . . . . . . . . . . .
15-2 1
Luggage Lamp
. . . . . . . .
.
..
. . . . . . .
15-23
Console
. . . . . . . . . . . . . . . . . . . . .
15-24
Radio and Front Speaker.
. . . . . . . . . . .
15-28
Radio Suppression Equipment
. . .
.
. . . . .
15-30
Manual Antenna
. . . . . . . . . . . . . . . .
.
15-32
Power Antenna
. . .
. .
. . . . . . . . . . . .
15-33
Overhaul
.
. . . . . . . . . . . . . . .
.
. .
15-36
Rear Seat Speaker
. . . . . . . . . . . . .
:
.
15-37
Verbra-Phonic System
. . . . . . . . . . . . .
15-39
Stereo Tape Player.
. . . . .
.
.
.
. . . . . .
15-41
FM Stereo Radio
. . . . .
. .
. .
.
. . . . . .
15-45
Stereo Speakers.
.
.
. . . .
. . .
.'. . . . . .
15-48
higher than selected speed, turn centering spring
adjusting screw (C) clockwise 1 /8" turn or less.
2. If Cruise Control holds speed three or more mph
below selected speed, turn antering spring adjusting
screw
(C) cgunterclockwise 1 /8" tuin or less.
CAUTION: Do not move adjustment
screw
(R). See
below
under
DISA SSEMBL Y.
VACUUM SOURCE
0
CENTERING SPRING
ADJUSTMENT S C R E W
Fig. 15-1 Adjustment Screw Identification