Carburetor Fuel Filter; Air Cleaner Element; Automatic Transmission; Cooling System - Pontiac Grand Prix Service Manual

0-12 1969 PONTIAC SERVICE MANUAL
CARBURETOR FUEL FILTER
-
INTEGRAL
Remove and clean bronze filter and filter cavity;
replace paper element.
AIR CLEANER
ELE'MENT
(PAPER)
-
STANDARD ON
ALL ENGINES
Replace.
NOTE: Clean and re-oil after each occasion of driving
under severe dust conditions. Allow excess oil to drain
out ofjlter prior to installation.
ITEMS REQUIRING LUBRICATION OR
SERVICE EVERY 24 MONTHS OR 24,000
MILES, WHICHEVER OCCURS FIRST
AUTOMATIC TRANSMISSION
Replace transmission fluid. Also replace oil filter in
sump of Turbo Hydra-Matic. Refill with DEXRON,
or equivalent, automatic transmission fluid. Under heavy-
duty operating conditions or excessive stop-and-go driving,
replace oil (and filter on Turbo Hydra-Matic) at 12,000-
mile intervals.
COOLING SYSTEM
Drain, flush with water, and refill to specified level
with special Pontiac ethylene glycol type coolant, part
number 1050027, 1050028, or equivalent.
ITEMS REQUIRING LUBRICATION OR
SERVICE AT SPECIAL INTERVALS
TIRES
Rotate tires every 6,000 miles and rebalance tire and
wheel assemblies as required.
PARKING BRAKE CABLES
Clean and lubricate during major brake service. Use
light water-resistant grease.
BRAKE ASSEMBLIES
CAUTION: Grease must be kept off brake linings:
remove by sanding.
MANUAL STEERING GEAR
Add lubricant as necessary. Change lubricant only
when necessary to disassemble. Use water resistant
EP
grease to level of center side cover bolt hole.
BODY DOOR LOCKS AND STRIKERS
Stick-type lubricant
-
use sparingly as required.
DOOR HINGE HOLD-PINS
Light grease on friction surface. Use sparingly as
required.
BODY DOOR HINGE PINS
Engine oil as required.
STATION WAGON FOLDING SEAT
b
Engine oil on pivots as required. Use sparingly.
FUEL DOOR HINGE
Engine oil on hinge pin and spring anchor points as
required.
REAR COMPARTMENT LID HINGES
Engine oil as required.
CONVERTIBLE FRONT DOOR-TO-LOCK WEDGE
PLATES
Stick-type lubricant, use sparingly as required.
WINDSHIELD WASHER SOLVENT
Use Pontiac solvent, part 10504 18, or .equivalent and
follow instructions on label to ensure proper operation
of washer, and to prevent paint damage from exces-
sively strong solutions.
-
A1.R CONDITIONING CONDENSER CORE
Clean and lubricate shoe pads, anchor pins, shoe hold
Clean off leaves and bugs and flush outside of
down spring pins (at contact area with backing plate)
condenser and radiator core to remove dirt annually
and adjusting screw at time of major brake service.
each spring.
Use only a high melting point lubricant and apply
sparingly.
CA UTION: Do not use steam.