Pontiac Grand Prix Service Manual page 522

73-62 1969
PONTIAC SERVICE MANUAL
1. Road test car to bring transmission fluid to
operating temperature, approximately 180".
2. Raise car on hoist or jack stand, engine running
with rear wheels free to turn, and locate source of oil
leak. Check for leaks with transmission in "LOW" and
"SUPER" ranges.
NOTE: Use of a mirror is he@@ in locating leaks.
3.
Shut engine off and thoroughly clean area to be
repaired with cleaning solvent and a brush, then air
dry.
NOTE: A clean , dry soldering acid brush may be used
to clean the area and also to apply the epoxy cement.
4. Following the instructions of the manufacturer, mix
a sufficient amount of epoxy cement, Part No.
1360016
(Z),
Grp. No.
0.423,
or equivalent, to make the repair.
NOTE: Observe manufacturefs cautions in handling.
5. While transmission case is still hot
,
apply .epoxy
cement to the area to be repaired. Be sure the area to
be repaired is completely covered.
6. If 1360016 (Z)
epoxy
is
used, allow THREE
(3)
hours to cure before starting enqine.
7. Road test car to bring transmission fluid to
operating temperature of
180"
and re-check transmis-
sion for leaks.
TORQUE SPECIFICATIONS
LB.
FT.
Pump Cover Bolts.
.
.
. . . . . .
. . . .
. . . . . . . . . .
.
. . .
18
Parking Pawl Bracket Bolts.
.
.
. .
.
. . .
. . . . . . .
. . .
18
Case Center Support Bolt..
.
. .
. . . .
.
. .
.
.
.
.
.
.
.
. .
22
Pump to Case Attaching Bolts..
. . . . .
.
.
. . . . . . . .
18
Extension Housing to Case Attaching Bolts.
. .
. .
22
Rear Servo Cover Bolts..
. . . . . .
.
. .
.
. . . .
.
.
. .
. . .
18
Detent Solenoid Bolts.
.
.
. . . . . .
.
. . . . . . . . . .
.
. . .
8
Control Valve Body Bolts..
. . . .
.
.
. . . .
. .
. . .
.
. . .
8
Bottom Pan Attaching Screws..
. .
.
. . .
.
. . .
.
. . . .
12
Modulator Retainer Bolt.
. . . . . . .
.
. . . . . . .
.
. .
.
.
18
Governor Cover Bolts..
.
. . .
. . . . .
. .
.
.
.
. . .
.
. .
. .
18
Manual Lever to Manual Shaft Nut..
.
. .
. . . . . . .
20
Linkage Swivel Clamp Nut (Firebird).
. . . .
.
.
. .
.
3 0
Linkage Swivel Clamp Screw (Except Firebird).
.
20
Transmission to Engine Mounting Bolts.
.
. .
. . . .
40
Rear Mount to Transmission Bolts..
. . ,
.
.
.
. . . . .
40
Rear Mount to Crossmember Bolt (Pontiac and
Firebird)
...
. . . . .
. .
.
. . . .
.
.
.
. . . . . .
. . .
. . . .
. . .
40
Rear Mount to Crossmember Bolt (Tempest and
Grand Prix).
. .
.
.
.
. .
. .
. . . . .
.
.
. . . . . . .
. .
. . . . .
55
Crossmember Mounting Bolts (Tempest and
Grand Prix).
. .
. . . . .
.
. . . . .
.
. . . .
. .
. . . .
. .
. . . .
3 0
Crossmember Mounting Bolts (Pontiac).
. . . . . . . .
18
Oil Cooler Line..
. . . . . .
. .
. . .
.
. . . . . . . . . . . . . .
.
.
16
Strainer Retainer Bolt..
. . .
.
.
. . . .
.
.
. . . . .
.
.
. . . .
10