Toyota Avensis ZZT251 2003 Service And Repair Manual page 1436

SUPPLEMENTAL RESTRAINT SYSTEM
Stripped Wire Harness Section
AVENSIS REPAIR MANUAL (RM1018E)
(b)
CAUTION:
Y
Y
H42620
(c)
Wire Harness
Diameter
CAUTION:
If a wire harness which is too thin or an alternative object
is used to tie down the instrument panel passenger airbag
assy, it may be snapped by the shock when the airbag is
H40008
deployed. This is highly dangerous. Always use a wire har-
ness for vehicle use which has a diameter of at least 1.25
2
mm
HINT:
Y
Y
CAUTION:
Y
Y
http://vnx.su
– INSTRUMENT PANEL PASSENGER AIR BAG ASSY
Remove the instrument panel passenger airbag assy
(See page 60–29).
When removing the instrument panel passenger air-
bag assy, work must be started 90 seconds after the
ignition switch is turned to the "LOCK" position and
the negative (–) terminal cable is disconnected from
the battery.
When storing the instrument panel passenger airbag
assy, keep the upper surface of the airbag deploy-
ment side facing upward.
Using a service–purpose wire harness for the vehicle, tie
down the instrument panel passenger airbag assy to the
tire.
Wire harness: Stripped wire harness section
2
1.25 mm or more (0.0019 in.
2
(0.0019 in. ).
To calculate the square of the stripped wire harness sec-
tion:
Square = 3.14 x (Diameter)
Position the instrument panel passenger airbag assy in-
side the tire with the airbag deployment side facing inside.
Tire size: Must exceed the following dimensions
Width: 185 mm (7.28 in.)
Inner diameter: 360 mm (14.17 in.)
Make sure that the wire harness is tight. It is highly
dangerous when looseness in the wire harness re-
sults in the instrument panel passenger airbag assy
coming free due to the shock from the airbag deploy-
ment.
Always tie down the instrument panel passenger air-
bag assy with the airbag deployment side facing in-
side the tire.
60–33
2
or more)
2
divided by 4