Chrysler 2005 Crossfire SRT6 Service Manual page 1443

ZH
WARNING: ON VEHICLES EQUIPPED WITH AIRBAGS, DISABLE THE SUPPLEMENTAL RESTRAINT SYSTEM
BEFORE ATTEMPTING ANY STEERING WHEEL, STEERING COLUMN, DRIVER AIRBAG, PASSENGER AIR-
BAG, SIDE IMPACT SENSOR OR INSTRUMENT PANEL COMPONENT DIAGNOSIS OR SERVICE. DISCON-
NECT AND ISOLATE THE BATTERY NEGATIVE (GROUND) CABLE, THEN WAIT TWO MINUTES FOR THE
SYSTEM CAPACITOR TO DISCHARGE BEFORE PERFORMING FURTHER DIAGNOSIS OR SERVICE. THIS IS
THE ONLY SURE WAY TO DISABLE THE SUPPLEMENTAL RESTRAINT SYSTEM. FAILURE TO TAKE THE
PROPER PRECAUTIONS COULD RESULT IN ACCIDENTAL AIRBAG DEPLOYMENT AND POSSIBLE PER-
SONAL INJURY.
1. During the following test, the battery negative cable remains disconnected and isolated, as it was during the SRS
component removal and installation procedures.
2. Connect the DRBIII to the Data Link Connector (DLC).
3. Exit the vehicle but maintain contact with the DRBIII .
4. Turn the ignition switch to the On position.
5. Check to be certain that there are no occupants in the vehicle, then reconnect the battery negative cable.
6. Using the DRBIII , read and record any active (current) Diagnostic Trouble Code (DTC) data.
7. Next, use the DRBIII to read and record any stored (historical) DTC data.
8. If any DTCs are found, refer to the appropriate diagnostic information.
9. Use the DRBIII to erase any stored DTC data.
10. Turn the ignition switch to the Off position for approximately fifteen seconds, and then back to the On position.
Observe the airbag warning indicator in the instrument cluster for proper operation. If a fault is detected, refer
to the appropriate diagnostic information.
SPECIFICATIONS
TORQUE CHART - RESTRAINTS
TORQUE SPECIFICATIONS
DESCRIPTION
Seat Belt Buckle Bolt
Seat Belt Guide Fitting
Bolt
Occupant Restraint
Controller Bolts to Vehicle
Floor
Side Impact Sensor Bolts
Passenger Airbag to
Instrument Panel Bolts
Airbag to Steering Wheel
Screw
Seat Belt End Fitting Bolt
Seat Belt Tensioner (SBT)
to B Pillar Bolt
RESTRAINTS - SERVICE INFORMATION 8O - 87
N·m
35
35
11
12
12
8
8
10
Ft. Lbs.
26
26
8
9
9
6
6
8
In. Lbs.
310
310
97
106
106
71
71
88