BOMBARDIER 1982 Shop Manual page 97

OIL INJECTION PUMP ADJUSTMENT
_ CAUTION: The carburetors must be adjusted be-
... fore adjusting the oil injection pump. Make sure
the idle speed is 1800-2000 R.P.M. and that the pump
lever stop is bent to 90 0 with the lever.
To synchronize pump with carburetor:
Eliminate the throttle cable free -play by pressing the
throttle lever until a light resistance is felt, then hold in
place. The pump lever stop should just touch the pump
body. If not, loosen the adjuster nut and adjust accord-
ingly .
Tighten the adjuster nut.
Adju stment
nuts
Bleeder
screw
""
Pump lever stop should just
touch the pump body
_ ~AUTI~N : Proper oil injection pump adjustment
... IS very Important. Any delay in the opening of the
pump can result in serious engine damage.
SECTION 02 ENGINE
SUB-SECTION 04 (454 ENGINE TYPE)
To bleed oil lines:
All oil lines should be full of oil. To bleed the main oil line
(between tank and pump), loosen the bleeder screw
and let the air escape until oil starts to flow out.
Make sure tank has enough oil
To bleed the small injector oil lines, start the engine and
let it run at idle speed. Move injection pump lever to fully
open position until lines are full of oil.
PAGE 95
----------------------------------------------
----