BOMBARDIER 1982 Shop Manual page 133

ADJUSTMENT
Always perform carburetor adjustment prior to oil injec-
tion pump adjustment.
To synchronize pump with carburetor:
Eliminate the throttle cable free-play by pressing the
throttle lever until a light resistance is felt, then hold in
place. The aligning marks on the pump casting and on
the lever must align. If not, loosen the adjuster nut and
adjust accordingly .
Tighten the adjuster nut.
Inject ion pump ca ble adj ustmen t
_ CAUTION: Proper oil
injecti~n
pump
a~justment
", is very important. Any delay
In
the opening of the
pump can result in serious engine damage.
SECTION 02 ENGINE
SUB-SECTION 05 (464 ENGINE TYPE)
To bleed oil lines:
All oil lines should be full of oil. To bleed the main oil line
(between tank and pump), loosen the bleeder screw
and let the air escape until oil starts to flow out.
Make sure tank has enough oil
To bleed the small injector oil lines, start the engine and
let it run at idle speed. Move injection pump lever to fully
open position until lines are full of oil.
PAGE 131