Toyota ZZT230 series Repair Manual page 22

FOR VEHI C LES EQUI P PED
CAUTION:
2.
l a rge amount of unburned gasol i n e fl o ws I n to the convert e r,
H
To prevent
ard.
( b )
Use
only unleaded gasoline.
(a)
Avoid prolonged Idling.
( c )
Avoid running the engine at idle speed for more than 20 minutes.
Avoid spark jump test.
W i
( 1)
Perform
( d )
h l e testing, never race the engine.
( 2)
Avoid prolonged engine compression measurement.
Engine compression tests must
Do not run engine when fuel tank is nearly empty.
{e)
( f )
This may cause the engine to misfire and create an extra load on the converter.
Avoid coasting with ignition turned off. Do not dispose of used catalyst along with parts contaminated with gasoline or oil.
(g)
I F VEHI C LE I S EQUI P PED WI T H MOBI L E COMMUNI C ATION SYSTEM
3.
For vehicles with mobile communication systems such as two-way radios and cellular telephones, observe
the following precautions.
( 1 ) Install the antenna as far as possible away from the ECU and sensors of the vehicle's electronic
)
system.
(2) Install the antenna feeder at least
hicle's electronic systems. For details about ECU and sensors locations, refer to the section on
the applicable component.
Avoid winding the antenna feeder together with other wiring as much as possible, and also avoid
( 3 )
running the antenna feeder parallel with other wire harnesses.
(4 ) Check that the antenna and feeder are correctly adjusted. Do not install powerful mobile communications system.
(5}
)
INTRODUCTION
WITH
observe the fol l o wi n g precauti o ns and expl a i n them to your customer.
this,
spark
jump test only when absolutely necessary. Perform this test as rapidly as possible.
be
-
FOAALLOFVEHICLES
A CATALYTIC CONVERTER
done as rapidly as possible.
20
em (7.87 in.} away from the ECU and sensors of the ve­
may overheat and create a
It
IN-17
haz­
fire