Stoplamp Switch Adjustment - GMC chevrolet camaro 2000 Service Manual

)
)
Brakes
Installation Procedure
1 . Install the Stoplamp and TCC switch (3) to the
bracket (1).
2. Connect the. electrical connector to the switch.
3.
Adjust the Stoplamp and TCC switch ... Refer
to Stop/amp Switch Adjustment.
4 . .Install the left side instrument panel insulator.
Refer to Closeout/Insulator Panel Replacement
- Left in Instrument Panel, Gauges and Console.
Stoplamp Switch Adjustment
Notice: Proper stoplamp switch adjustment is
essential. Improper stoplamp switch adjustment may
cause brake drag, heat buildup and excessive
brake lining wear.
1. Adjust the cruise control release switch (2) and
the stoplamp and Torque Converter Clutch (TCC)
switch (3) at the same time.
· 2. Adjust the cruise control clutch switch (4) or the
cruise control clutch anticipate switch (6) if
equipped after the clutch pedal is installed.
3. Depress the brake or the clutch pedal.
4. Insert the following switches into the pedal ' 1 1.' . ith
the bracket until the retainers on the switches
are fully seated:
• Cruise control release switch (2)
• Stoplamp and TCC switch (3)
• Cruise control clutch switch (4) or cruise
control clutch anticipate switch (6) if equipped.
Important: Apply the proper amount of force to the
brake pedal during adjustment.
• Too much force may damage the vacuum
booster.
• Too little force may cause the brakes to drag.
5. Slowly pull the brake or clutch pedal rearward
with a force of 222 N (50 lbs) until clicking
sounds are no longer heard. At this point, the
retainers on the switches will be adjusted.
6. Measure the cruise control release switch (2).
7. Measure the stoplamp and TCC switch (3).
8. The switch contacts should be open at
25.4 mm (1.0 in) or less of pedal travel. The switch
contacts should occur at the same time or
before the onset of braking. The brake pedal
travel can be up to 25.4 mm (1.0 in) before the
cruise control system disengages.
Hydraulic Brakes 5-51
1
..
------------,
._--1
I
I
. .
~
-L_ -----. ,
6
OPTIONAL
L.----------..1
4
3
374062
182813