GMC chevrolet camaro 2000 Service Manual page 753

24
Power Steering (cont.)
Diagnosis
Excessive Wheel Kickback or Loose
Steering ............................................ 2-10
Foaming, Milky-Appearing PS Fluid,
Low in Level .................................... 2-12
Gear and Pump Leaks ................................. 2-7
Groan Noise in Steering Pump ................... 2-13
Growl Noise in Steering Pump .............. , .... 2~13
Hissing Noise in Steering Gear ......... , .......... 2-7
Increase in Effort While Turning .................. 2°10
Low Oil Pressure Due to Steering Gear ..... 2-12
Low Oil Pressure Due to Steering Pump .... 2-12
Poor Return of Steering Wheel ................... 2-11
Rattle Noise .in Rack and Pinion ................... 2-7
Seal Replacement Rec.ommendations ........... 2s9
Steering Effort Hard in Both Directions ....... 2-11
Steering Wheel Kickback ...... , ............... ,., ... 2-11
System Test Procedure .......... : ....... ;;: ........... 2-9
Too Much Play in Steering ......................... 2-11
Vehicle Leads to One Side or the Other ..... 2-12
Wander or Poor Steering Stability ................ 2-12
Wheel Surges or Jerks While Turning ........ 2-11
Whine Noise in Steering Pump ................... 2-13
Flushing the System ...................................... 2-28
Gear Replacement ................................ 2~32, 2-34
Pulley Replacement ................................. , ..... 2-20
Pump Front Bracket Replacement .................. 2-26
Pump Rear Bracket Replace .......................... 2-27
Pump Replacement ........................... , ... 2-21, 2-22
Rack and Pinion
Boot Replacement ............................ , ......... 2~35
Steering Gear Cylinder Pipe Assemblies/
0-Ring Seals - Off Vehicle ............... 2-43
Rack Bearing Pre load .................................... 2-35
Remote Fluid Reservoir Bracket
Replacement .................................... 2-19
Remote Fluid Reservoir Replacement ............ 2-18
Reservoir Replacement .................................. 2-24
Return Hose Replacement ............................. 2-30
Special Tools ................................................. 2-48
Specifications
Fastener Tightening ...................................... 2-3
Fluid Specifications ...... , ................................ 2-3
GM SPO Group Numbers ............................ 2-3
Tie Rod Replacement - Inner ......................... 2-41
Tie Rod. Replacement - Outer
O
Off Vehicle .... 2-38
Power Steering Gear
Visual Identification
Disassembled View ...................................... 2-4
Power Steering Pump
Visual Identification
Disassembled View ............................... 2-5, 2-6
Power Windows .............................................. 8-905
Diagnosis
Inoperative ................................................ 8-906
Left Front .............................................. 8-906
Inoperative from LF Switch ....................... 8-91 O
Inoperative from RF Switch ....................... 8-910
Inoperative RF from LF Switch ................. 8-907
Inoperative Right Front ............................. 8-908
Power Windows Inoperative ...................... 8-906
Left Front ......... , .................................... 8-906
INDEX
Power Windows (cont.)
s.witch Replacement .......................... 8-911, 8-912 (
Powertrain Control Module
Air Conditioning Control Diagnosis (3.8L) ... 6,·1189
Connector End Views (3.8L) ........................ 6-814
Connecto_r End Views (5.7L) ....... , ............... 6-.1368
Controlled Air Conditioning
Description (3.8L) , ........................ 6~1305
Controlled Generator Description (3.8L) ..... , 6-1306
Controlled Warning Lamps
Description (3.8L) ......................... 6-1304
Description (3.8L) ....................................... 6-1300
Description (5.7L) ....................................... 6-1932
Diagnosis (3.8L) ......................................... 6-1188
Replacement/Programming (3.8L) ............... 6-.1232
Powertrain Control Module Idle Learn
Procedure (5.7L) ........................... 5:1840
Pressure Relief Valve Replacement ............... B-1109
Programming Additional Keys -
Theft Deterrent ............................... 8-705
Programming/Replacement
Powertrain Control Module (3.8L) ............... 6.-1232
Programming/RPO Configuration of the
Body Control Module ...................... 8-543
Programming/Synchronization
Key less Entry Transmitter ............................. 8-66.1
Propeller Shaft
Description ................................................ :;· ... · 4-18
Center Bearing ........................................... 4-19
Phasing ...................................................... 4-19 (
Universal Joint ............................................ 4-19
Diagnosis . . . . . . . . . . . . . . .. .. . . . . . . . . .. . . . . . . . .. . . . . . . . . .. .. . .. .. . . 4-4
Leak at Front Slip Yoke ............................... 4~5
Noise ........................................................... 4-7
Knock or Clunk Noise ............................ .' .. 4-7
Ping, Snap, or Click Noise ........................ 4-6
Scraping Noise . . . . . . . . . . . . . . .. . . ..... . . . . . . . .. . .. .. .. .. . 4-7
Roughness or Vibration ................................ 4-5
Shudder on Acceleration at Low Speed ........ 4-7
Propeller Shaft Replacement, One-Piece .......... 4-8
Propeller Shaft Replacement, Two-Piece ........ 4-10
Special Tools ................................................. 4-20
Specifications
Fastener Tightening ......................... , ............ 4-3
GM SPO Group Numbers ............ : ............... 4-3
Runout Specifications ................................... 4-3.
Universal Joint and Slip Yoke Replacement ... 4-14
Propeller Shaft Balancing Weight Amounts ..... , .. 0-42
Propeller Shaft Runout Specifications ................ 0-42
Pump, Fuel, Module Replacement (5.7L) ...... , 6-1881
Q
Quarter Panel Replacement .............. 8-1213, 8-1216
Quick Connect Fitting Service (
Metal Collar (3.8L) ..................................... 6-1248
Metal Collar (5.7L) ..................................... 6-1864
Plastic Collar (3.8L) .................................... 6-1250
Pla?tic Collar (5.7L) .................................... 6-1866