GMC chevrolet camaro 2000 Service Manual page 740

INDEX
Engine Coolant Temperature Sensor
Replacement (5.7L) ....................... 6-1841
Engine Coolant Temperature Sensor
Replacement
(Engine Cooling) .................. 6-650, 6-651
Engine Cooling
Component Views ........................................ 6-599
Components ...................... , .............. , . . . . . . . . . . . 6-598
Connector End Views . . . . . .. . . . . . . . . .. .. . .. .. . . .. . .. . . . . 6-600
Description
Air Baffles and Seals ................................ 6-673
Coolant .................................................... ·. 6-669
Coolant Heater .. .. .. . . . . . .. .. .. . .. . . . . .. .. .. . .. . . . . .. .. 6-670
Coolant Recovery System ......................... 6-669
Cooling Fan Relay ............ , ....................... 6-672
Cooling System .............. , ......................... 6-669
Electric Engine Cooling Fan ...................... 6-671
Engine Coolant Temperature Sensor ........ 6-672
Radiator Assembly ............................... , .... 6-670
Radiator Filler/Pressure Cap Assembly ..... 6-671
Thermostat ............................................ , .. 6-672
Throttle Body Coolant System .................. 6-670
Water Pump ............................................. 6-672
Diagnosis
Coolant Concentration Testing ............... , .. 6-604
Cooling System Leak Testing ........ : .......... 6-606
Engine Fails To Reach Normal
Operating Temperature ................... 6-604
Loss of Coolant . . . . . . .. .. . .. . . . . .. . . .. . .. .. . . .. . .. . .. . . 6-602
Overheating .......................... , ................... 6-601
Pressure Cap Testing ............................... 6-608
Thermostat ................................... , ........... 6-604
Schematic
Cooling Fan ............................. , ............ · .... 6-596
Cooling System Icons .. .. . . .. . .. .. . .. .. .. .. .. .. . .. . . 6-595
Special Tools ............................................... 6-673
Specifications
Engine Cooling System .............. , .............. 6-594
Fastener Tightening .................................. 6-594
GM SPO Group Numbers ......................... 6-594
Engine Diagnosis
Exhaust Leakage ...................... , . . . . . . . . . . . . . . . . 6-1976
Engine Electrical
Component Locations .. . . . .. . . . . . .. .. ... .. . . . . . . .. .. .. . . 6-680
Description
Battery ...................................................... 6-781
Battery Operation ...................................... - 6-781
Battery Tray and Hold-Down Retainer ....... 6-782
Charging System ...................................... 6~ 782
Charging System Circuit .. . . . . .. .. .. . .. .. .. . . . .. . . . 6-783
Charging System Operation ...................... 6-783
Ignition System .............................. 6-783, 6-784
Ignition System Operation ......................... 6-784
Starting System ........................................ 6-780
Starting System Circuit ............................. 6-780
Starting System Operation ........................ 6-780
Diagnosis
Battery Common Causes of Failure .......... 6-692
Battery Hydrometer Displays Dark or
Yellow Dot .. . . . . . . . .. .. .. .. . . . . . .. . . .. .. .. . .. .. . 6-700
Battery Hydrometer Displays Yellow Dot ... 6-694
Battery Load Test - Parasitic .................... 6-700
Battery Not Operating Properly . . . . .. . .. . . . . . . .. 6-696
Battery Terminal Check ............................. 6-693
Engine Electrical (cont.)
Diagnosis (cont.)
Battery Visual Inspection ........................... 6-693
Diagnostic Starting Point -
Engine Electrical ........................... ,. 6-686
Engine Cranks/Cranks Slowly,
but Does Not Start ................ , .. .. .. .. 6-690
Generator Assembly Check .. . . • . .. .. .. .. . .. .. . . . 6-706
Generator Not Operating Properly ............. 6-704
Spark Plug Visual ..................................... 6-707
Spark Plug Wire Harness ......................... 6-709
Starter Motor Noise ............................ , ..... 6-691
Starter No Load Test .............................. ,. 6-692
Starter Solenoid Clicks,
Engine Does Not Crank .................. 6-688
Starter Solenoid Does Not Click .. .. . . . .. . . . .. . 6-687
Symptoms - Engine Electrical ................... 6-686
Generator Brace Replacement ..................... 6-763
Generator Bracket Replacement ....... 6-761, 6-762,
6-763
Generator Replacement . . .. . .. .. . .. .. .. . .. .. 6· 764, 6-766
Generator Splash Shield Replacement ......... 6-769
Ground Strap Replacement ...................... ; ... 6-759
Ignition Coil Module Replacement ..... , .......... 6-777
Ignition Coil Replacement .................. 6-775, 6-776
Schematic
Starting and Charging Icons ..................... 6-676
Schematics
Starting and Charging ..................... , ......... 6-677
Spark Plug Replacement .................... : .. . . . . . .. 6-77 4
Spark Plug Wire Harness
Replacement ............. 6-770, 6-772, 6-773
Special Tools .. . . . . . .. .. .. .. .. .. .. .. . .. .. . .. . .. . . . .. . .. .. .. . 6-785
Specifications
Battery Temperature vs Voltage Drop ....... 6-675
Battery Usage Table .: ............................... 6-674
Fastener Tightening .................................. 6-67 4
Generator Usage .: .................... , ............... 6-675
GM SPO Group Numbers ......................... 6-676
Spark Plug Usage Table ........................... 6-675
Spark Plug Wire Resistance .................... , _6-676
Starter Motor Usage Table ............... : ....... 6-675
Starting and Charging Component Views ..... 6-682
Starting and Charging
Connector End Views ..................... 6-686
Underhood Fuse Block (UBEC) .
Replacement ................... , . . . . . . . . . . . . . . 6-7 41
Engine Exhaust
Catalytic Converter Replacement ............ ,... 6-1980
Converter Hanger Assembly
Replacement ....... 6-1991, 6-1992, 6-1993
Converter Heat Shield Replacement ........... 6-1998
Description
Catalytic Converter ............................... , . 6-2003
Clamps . . . .. .. .. .. . . . . . . . . . .. . .. . .. . . . . • .. .. . .. . . . . . . . . . . . 6,2003
Exhaust System . .. . . .. .. .. . .. .. . .. . . .. .. .. .. . .. .. . . .. 6-2003
Hangers ............................ , ..................... 6°2003
Muffler .................................................... 6-2003
Diagnosis
Exhaust Noise ........................................ 6-1975
Internal Muffler Rattles/Loss of Power ..... 6-1976
Restricted Exhaust .. .. .. . .. . .. . . . .. .. . .. . .. .. . . . . .. . 6-197 4
Vibration or Rattling ................................ 6-197 4
Engine Mount Heat Shield Replacement .... 6-1997