Fip-1.33 Toner Cartridge Y/M/C/K Is Out; Fip-1.34 Pcdc Error - Epson ColorPage EPL-C8200 Service Manual

EPSON ColorPage EPL-C8200

FIP-1.33 TONER CARTRIDGE Y/M/C/K is Out

Step Check point
Perform the preliminary inspection.
1
Parts to inspect:
Toner Cartridge, CARTRIDGE SENSOR, MCU PWB
Check: Sticker on a Toner Cartridge

2
Is a white reflective sticker attached to the relevant
Toner Cartridge?
Check: CARTRIDGE SENSOR installation

3
Is the CARTRIDGE SENSOR properly installed?
Check: Toner Cartridge replacement
4
Replace the relevant Toner Cartridge with a new one.

Does the problem still occur?
Check: CARTRIDGE SENSOR

Is the CARTRIDGE SENSOR properly functioning?
5
Diag Tool: Digital Input Test
Device code: 0D

FIP-1.34 PCDC Error

Step Check point
Perform the preliminary inspection.
1
Parts to inspect: MCU PWB
Isolation: Engine or Controller?
Run the Engine test print or diagnostic test print.
2
(10 sheets for each of single and continuous print)

Are the outputs normal?
Check: MCU PWB replacement
3
Replace the MCU PWB.

Does the problem still occur?
Chapter 5 Troubleshooting
Yes
Replace/reinstall the defective part(s).
Go to Step 3.
Go to Step 4.
• With the diagnostic tool, go to step 5.
• Without the diagnostic tool, go to
FIP-2.22 "CARTRIDGE SENSOR is
Defective".
Replace the MCU PWB.
Yes
Replace/reinstall the defective part(s).
Check the Controller PWB.
If the problem still occurs, go to step 3.
Go to FIP-2.39 "Electrical Noise".
Remedy
No
Go to Step 2.
Replace the relevant Toner Cartridge.
Install the CARTRIDGE SENSOR
properly.
Problem solved.
Go to FIP-2.22 "CARTRIDGE SENSOR
is Defective".
Remedy
No
Go to Step 2.
Go to Step 3.
Problem solved.
Revision A
5-51