Windshield Wiper & Washer; Headlamp Washer Relay Open/Short To Ground (Export Only) - Dodge ZB 2005 Service Manual

Symptom:
HEADLAMP WASHER RELAY OPEN/SHORT TO GROUND (EX-
PORT ONLY)
When Monitored and Set Condition:

HEADLAMP WASHER RELAY OPEN/SHORT TO GROUND (EXPORT ONLY)

When Monitored: With the Ignition On.
Set Condition: This DTC will set if the BCM detects a lack of voltage on the Headlamp
Washer Pump Relay Control circuit.
DTC PRESENT
FAULTY HEADLAMP WASHER PUMP RELAY
HEADLAMP WASHER PUMP RELAY CONTROL CIRCUIT SHORT TO GROUND
OPEN B(+) CIRCUIT
OPEN EXPORT ACCESSORY FUSE
OPEN FUSED B(+) CIRCUIT
OPEN HEADLAMP WASHER PUMP RELAY CONTROL CIRCUIT
BODY CONTROL MODULE
TEST
1 With the DRBIII , record and erase DTC's.
With the DRBIII , read DTC's.
Attempt to operate the Headlamp Washers while monitoring the DRBIII .
Does the DRBIII
GROUND?
Yes → Go To 2
→ The condition that caused this DTC to set is currently not present.
No
2 Turn the ignition OFF.
Remove the Export Accessory Fuse holder from the fuse cover.
Inspect the Export Accessory Fuse.
Is the Export Accessory Fuse blown?
Yes → Replace the Export Accessory Fuse. Inspect the circuit for a
→ Go To 3
No
POSSIBLE CAUSES
ACTION
display HEADLAMP WASHER RELAY OPEN/SHORT TO
Using the wiring diagram/schematic as a guide, inspect the
related wiring harness and connectors for a possible intermittent
condition.
Perform BODY VERIFICATION TEST - VER 1.
possible failure that would cause a blown fuse.
Perform BODY VERIFICATION TEST - VER 1.
WINDSHIELD WIPER & WASHER
399
APPLICABILITY
All
All