Club Car Gasoline Service Manual page 407

• Batteries have discharged to less than 25% of rated capacity.
• If AC power is interrupted during the charge cycle, the light will turn on and remain on as long as the
DC cord is plugged in. This indicates that the batteries did not receive a full charge. The light will go out
when AC power is restored or the DC cord is unplugged.
• The warning light will come on and remain illuminated if the charger times out at 16 hours (see charger
owner's manual) and the batteries are not sufficiently charged. This indicates an abnormal charge
cycle and that the batteries or charger should be tested. The warning light will remain illuminated as
long as the DC cord is plugged in. The light will go off when the DC cord is unplugged.
• When the DC cord is unplugged before the charger times out, the warning light will come on and
remain illuminated for 10 seconds if the charge is less than 90% complete but the vehicle has enough
power to complete 36 holes of golf. If the charge is more than 90% complete, the light will not come on.
• After batteries have been disconnected and then reconnected, the warning light will come on for 10
seconds when either the accelerator pedal is depressed or the charger DC cord is plugged in.
The Battery Warning Light Circuit consists of:
• The warning light.
• The brown wire from the on-board computer to the warning light.
• The orange/white wire from the warning light to the key switch.
• The green wire from the key switch to the large post on the main solenoid.
SPADE
CONNECTOR
FIGURE 21-15
REVERSE BUZZER CONTROL CIRCUIT (FIGURE 21-16, PAGE 21-16)
The reverse buzzer is to alert the operator and anyone near the vehicle that the vehicle is in reverse. The
buzzer is mounted behind the center dash panel under the vehicle's front body.
The Reverse Buzzer Control Circuit consists of:
• The reverse buzzer.
• The forward and reverse rocker switch.
• The 18 gauge red wire from the reverse buzzer to the large post of the main solenoid.
• The 18 gauge orange wire from the reverse buzzer to the forward and reverse rocker switch.
• The 18 gauge black wire from the forward and reverse rocker switch to the B- terminal on the controller.
21A
E
Page 21-15