19B; Key Switch - Club Car Gasoline Service Manual

Electrical Components, Continued:

19B

WARNING
E
• TO AVOID UNINTENTIONAL STARTING OF THE VEHICLE, DISCONNECT BATTERIES AS
SHOWN IN FIGURE 19-1, PAGE 9-2.

KEY SWITCH

The key switch is mounted just to the right of the steering column on the center dash panel.
Testing the Key Switch
See Test Procedure 2, Page 19-10.
Removing the Key Switch
1. Disconnect the batteries (Figure 19-1, Page 19-2).
2. Remove the center dash.
2.1. Remove the plastic cap covering the screw on each side of the center dash.
2.2. Loosen (but do not remove) the screw on each side of the center dash panel.
2.3. Insert a screwdriver at the top center of the center dash between the dash and cowl brace. Gently
pry the center dash out slightly from under the edge of the cowl brace.
2.4. Pull the center dash out approximately one inch from the frame and then bend the top right corner
of the center dash panel inward while pulling the top of the panel out and down.
NOTE
• BENDING THE TOP RIGHT CORNER OF THE CENTER DASH INWARD WHILE REMOVING IT
WILL PREVENT THE CONTACTS ON THE REAR OF THE KEY SWITCH FROM TOUCHING THE
METAL FRAME AROUND THE DASH.
Page 19-18
8
5
9
6
FIGURE 19-11