Club Car Gasoline Service Manual page 134

11
SYMPTOM
Starter fails to operate, continued:
G
Starter/generator does not charge
battery.
Transmission does not engage or
disengage smoothly.
Excessive vehicle
vibration.
Page 11-4
POSSIBLE CAUSES
6. Starter solenoid failed
7. Accelerator limit switch failed
8. Key switch failed
9. Neutral lock-out limit switch
failed
10. Loose or broken wire in
starter/generator circuit
1. Loose or broken wire in the starter/gen-
erator circuit
2. Generator field coil is shorted
3. Brushes are worn or
commutator is dirty
4. Starter/generator belt is
loose or slipping
5. Voltage regulator failed
6. Battery failed
1. Transmission shifter linkage is binding
or is out of adjustment
2. Insufficient (low) level of lubricant, or
wrong type of lubricant in transmission
3. Internal gears are damaged or worn
4. Synchronizer rings are worn, damaged
or jammed
1. Engine mounting nuts or bolts are
loose
2. Defective or worn engine mounts
3. Rubber snubber on inner-frame is worn
or damaged
4. Misaligned muffler mounting clamp
5. Damaged drive belt or starter belt
6. Damaged drive clutch
7. Damaged driven clutch
REFER TO
Section 12, Gasoline Vehicle
Electrical System -
Starter circuit
Section 12, Gasoline Vehicle
Electrical System -
Starter circuit
Section 12, Gasoline Vehicle
Electrical System -
Starter circuit
Section 12, Gasoline Vehicle
Electrical System -
Neutral lock-out circuit
Section 12, Gasoline Vehicle
Electrical System -
Starter/generator
Section 12, Gasoline Vehicle
Electrical System -
Starter/generator
Section 12, Gasoline Vehicle
Electrical System -
Starter/generator
Section 12, Gasoline Vehicle
Electrical System -
Starter/generator
Section 12, Gasoline Vehicle
Electrical System -
Starter/generator
Section 12, Gasoline Vehicle
Electrical System -
Generator circuit
Section 12, Gasoline Vehicle
Electrical System
Section 17, Transmission
Section 17, Transmission
Section 17, Transmission
Section 17, Transmission
Section 13, Engine
Section 13, Engine
Section 13, Engine
Section 15, Exhaust System
Section 16, Torque Converter
Section 16, Torque Converter
Section 16, Torque Converter