Club Car Gasoline Service Manual page 70

Removing the Park Brake Assembly, Continued:
6
2. Place chocks under the rear wheels and lift the front end of the vehicle with a chain hoist or floor jack.
Place jackstands under the front cross tube of the vehicle frame and lower the vehicle onto the jack-
E
stands. See WARNING below.
G
WARNING
• LIFT ONLY ONE END OF A VEHICLE AT A TIME. BEFORE LIFTING, LOCK THE BRAKES AND
CHOCK THE WHEELS THAT REMAIN ON THE FLOOR. USE A SUITABLE LIFTING DEVICE
(CHAIN HOIST OR HYDRAULIC FLOOR JACK) WITH 1000 LBS. (454 KG.) MINIMUM LIFTING
CAPACITY. DO NOT USE LIFTING DEVICE TO HOLD VEHICLE IN RAISED POSITION. ALWAYS
USE APPROVED JACKSTANDS OF PROPER WEIGHT CAPACITY TO SUPPORT THE VEHICLE.
3. Remove the park brake assembly (See Page 6-11). See NOTE below.
NOTE
• THE PROCEDURE FOR REMOVING THE PARK BRAKE ASSEMBLY IS THE SAME AS IT IS FOR
EARLY 1995 VEHICLES (SEE PAGE 6-11).
Installing the Park Brake Assembly
1. Install the park brake assembly (See Page 6-11). See NOTE below.
NOTE
• THE PROCEDURE FOR INSTALLING THE PARK BRAKE ASSEMBLY IS THE SAME AS IT IS FOR
EARLY 1995 VEHICLES.
REMOVING THE ACCELERATOR PEDAL ASSEMBLY
DS V-Glide Electric Vehicles (Serial Number 9529 445799 and Later) and DS Gasoline
Vehicles (Serial Number 9529 445519 and Later).
(For PowerDrive System 48 and PowerDrive Plus vehicles, see page 6-27).
1. Make sure the key switch is off and that the Forward and Reverse Switch is in neutral, then disconnect
the battery(ies):
• DS V-Glide vehicle - disconnect the batteries as shown (Figure 22-5, Page 22-5).
• DS Gasoline powered vehicle - disconnect both battery cables, negative first.
2. Place chocks under the rear wheels and lift the front end of the vehicle with a chain hoist or floor jack.
Place jackstands under the front cross tube of the vehicle frame and lower the vehicle onto the jack-
stands. See WARNING below.
WARNING
• LIFT ONLY ONE END OF A VEHICLE AT A TIME. BEFORE LIFTING, LOCK THE BRAKES AND
CHOCK THE WHEELS THAT REMAIN ON THE FLOOR. USE A SUITABLE LIFTING DEVICE
(CHAIN HOIST OR HYDRAULIC FLOOR JACK) WITH 1000 LBS. (454 KG.) MINIMUM LIFTING
CAPACITY. DO NOT USE LIFTING DEVICE TO HOLD VEHICLE IN RAISED POSITION. ALWAYS
USE APPROVED JACKSTANDS OF PROPER WEIGHT CAPACITY TO SUPPORT THE VEHICLE.
Page 6-24