Club Car Gasoline Service Manual page 54

1995-1996 ds golf cars
Table of Contents

Advertisement

Adjustment the Accelerator Pedal Stop - Early 1995 Electric Vehicles, Continued:
6
E
G
ACCELERATOR ROD
4.5. Check the park brake ratchet/pawl gap. It should be between .030 and .125 inches (.08-.32 cm)
(Figure 6-11). If the gap is not at least .030"(.08 cm), adjust the accelerator pedal stop bumper to
widen the gap to between .030" and .050" (.08-1.27 cm). If the gap is greater than .125" (.32 cm),
adjust the accelerator pedal stop bumper to decrease the gap to between .110" and .125" (.28-.32
cm). If it was necessary to adjust the ratchet/pawl gap, then it will be necessary to repeat steps
4.2, 4.3, and 4.4. See NOTE below.
NOTE
• FOR SOME VEHICLES, IT MAY BE NECESSARY TO ADJUST THE ACCELERATOR PIVOT ROD
SUPPORTS (21) (FIGURE 6-7, PAGE 6-5) FORWARD OR BACKWARD TO ACHIEVE THE
PROPER ADJUSTMENTS. AFTER MOVING THE PIVOT ROD SUPPORTS, ALL ADJUSTMENTS,
STARTING WITH THE ACCELERATOR ROD ADJUSTMENT, MUST BE DONE AGAIN.
• IF THE GAPS CANNOT BE BROUGHT WITHIN THE LIMITS, CHECK FOR BENT, DAMAGED, OR
EXCESSIVELY WORN PARTS. BENT, DAMAGED, OR WORN PARTS MUST BE REPLACED IN
ORDER TO ACHIEVE THE PROPER ADJUSTMENTS.
5. ADJUST THE PARK BRAKE (See page 6-9 for electric vehicles).
• Adjust the Park Brake - Early 1995 Gasoline Vehicles:
5.1. Inspect the park brake pawl and latch for excessive wear, grooves, cracks, or chipping. If either
the pawl or latch is damaged, both must be replaced.
5.2. Make sure the brake pedal and cable are adjusted as instructed in steps 1 and 2 (Pages 6-2 and
6-3).
5.3. Disconnect the push rod (10) from the accelerator pedal (1) (Figure 6-5, Page 6-3). See DAN-
GER below.
DANGER
• TURN KEY SWITCH OFF, PLACE FORWARD AND REVERSE LEVER IN THE NEUTRAL POSI-
TION, AND REMOVE KEY BEFORE SERVICING THE VEHICLE.
• TO AVOID UNINTENTIONAL STARTING OF THE VEHICLE, ALWAYS BEFORE SERVICING:
- DISCONNECT BATTERY CABLES, NEGATIVE (-) FIRST.
- DISCONNECT THE SPARK PLUG WIRE FROM THE SPARK PLUG.
Page 6-8
.100" (2.5mm) MAXIMUM CLEARANCE
WIPER SWITCH
FIGURE 6-10
STOP BUMPER
WIPER SWITCH ARM

Hide quick links:

Advertisement

Table of Contents
loading

Table of Contents