Fuel Lines; Fuel Tank Vent - Club Car Gasoline Service Manual

FUEL LINES

14
The fuel lines on the DS gasoline vehicle must be properly routed, and all hose clamps must be tight. The
G
fuel lines should be kept clean.
WARNING
• MAKE SURE THAT THE FUEL LINES ARE THE RIGHT LENGTH AND ARE PROPERLY ROUTED.
FAILURE TO HEED THIS WARNING COULD RESULT IN DAMAGE TO THE FUEL LINES AND
FIRE.
Fuel line No. 1 runs directly from the fuel tank to the primary fuel filter. The primary fuel filter has an arrow
indicating fuel flow direction and has a white filter element inside of it (Figure 14-13, Page 14-18).
Fuel line No. 2 runs directly from the primary fuel filter to the fuel inlet of the fuel pump.
Fuel line No. 3 runs directly from the fuel outlet of the fuel pump to the secondary fuel filter. The secondary
fuel filter has an arrow indicating fuel flow direction and has a blue filter element inside of it.
Fuel line No. 4, a black 2 1/4 inch fuel line, runs from the outlet of the secondary fuel filter to the carburetor.
Small round dual wire clamps or spring steel band clamps are used on all hose connections except at the
carburetor. A screw band clamp is used at the carburetor (Figure 14-13, Page 14-18).

FUEL TANK VENT

WARNING
• TO PREVENT VENT TUBE FROM BEING CRIMPED AGAINST THE VEHICLE BODY, THE FUEL
TANK VENT AND TUBE MUST BE ORIENTED AS SHOWN IN FIGURE 12-16.
VENT TUBE
Page 14-24
VENT
GAS TANK GAS TANK
FIGURE 14-16