Club Car Gasoline Service Manual page 322

19A
SYMPTOM
E
4. Vehicle runs slow, continued:
5. Vehicle runs in first speed
when the F&R Switch is put in
forward or reverse with the
keyswitch OFF.
6. Vehicle runs in first speed
when the F&R Switch is put in
forward or reverse with the
key switch ON.
7. Vehicle will run in forward but
not in reverse, or will run in
reverse but not forward.
8. Vehicle not being fully
charged.
Page 19-6
V-GLIDE TROUBLESHOOTING GUIDE
PROBLEM
Batteries
Accelerator Push Rod
Motor
Brakes
Tires
Solenoid
Accelerator Pedal
Limit Switch
Accelerator Rod
V-Glide Wiper Switch
F&R Anti-arcing Limit Switch
Battery Wires
Charger Connections
On-board Receptacle Fuse
Link
Charger
POSSIBLE CAUSES
1) Loose terminals or corrosion. Test Procedure 1 and Batter-
2) Improperly wired.
3) Batteries failed.
4) Batteries not fully charged.
1) Accelerator rod is improperly
adjusted.
1) Loose wires.
2) Worn or misaligned brushes.
3) Dirty or rough commutator.
1) Dragging brakes.
1) Under-inflated or flat tires.
1) Solenoid contacts are
welded closed.
1) V-Glide wiper switch is
wired wrong.
2) Accelerator Pedal limit switch
failed in the closed position.
1) Accelerator rod is bent or
improperly adjusted.
1) Wiper switch brush or accel-
erator pedal is stuck.
2) Wiper switch is improperly
adjusted.
1) Broken 6 gauge green wire.
2) Dirty or corroded contacts on
the F&R switch.
1) Improperly wired
1) Loose wires at receptacle,
batteries, or F&R switch.
2) Improper engagement of
charger plug and receptacle.
1) Fuse is blown.
1) Incorrect incoming AC volt-
age.
2) Charger output is low.
3) Charger cord and plugs.
REFER TO
ies, Section 22, Page 22-5
V-Glide Wiper Switch,
Page 19-25
Motor,
Section 24, Page 24-8
Brakes, Section 6, and
Accelerator, Section 7
Wheels and Tires,
Section 10, Page 10-1
Test Procedure 9
Accelerator Pedal Limit
Switch, Page 19-20
Accelerator Pedal Limit
Switch, Page 19-20
Accelerator and Brake Pedal
Group,
Section 6
Accelerator and Brake Pedal
Group,
Section 6
Accelerator and Brake Pedal
Group,
Section 6
Test Procedure 3 and
Electrical Components,
Page 19-19
Accu-Power Charger,
Section 23A
Accu-Power Charger,
Section 23A
Accu-Power Charger,
Section 23A
Accu-Power Charger,
Section 23A
Accu-Power Charger,
Section 23A