Forward And Reverse Switch; Reverse Buzzer - Club Car Gasoline Service Manual

1995-1996 ds golf cars
Table of Contents

Advertisement

Key Switch, Continued:
21B
Installing the Key Switch:
E
See Installing the Key Switch, Page 20-26.

FORWARD AND REVERSE SWITCH

DANGER
• TURN THE KEY TO OFF, PUT THE FORWARD AND REVERSE SWITCH IN NEUTRAL, AND DIS-
CONNECT THE BATTERY CABLES AS SHOWN IN FIGURE 21-2, PAGE 21-3. FAILURE TO DO
SO MAY CAUSE THE VEHICLE TO RUN OVER YOU, RESULTING IN SEVERE INJURY OR
DEATH.
WARNING
• WHEN MAKING ELECTRICAL TESTS OR REPAIRS, ALWAYS:
- WEAR SAFETY GLASSES OR APPROVED EYE PROTECTION.
- REMOVE THE KEY.
- PUT THE FORWARD AND REVERSE SWITCH IN NEUTRAL.
- DISCONNECT THE BATTERIES AS SHOWN (FIGURE 21-2, PAGE 21-3).
- FOLLOW ALL PROCEDURES EXACTLY AS STATED.
• SEE THE SAFTEY WARNINGS ON PAGE 21-53.
Testing the Forward and Reverse (F&R) Switch
See Test Procedure 17, Page 21-37
Removing the Forward and Reverse (F&R) Switch
1. Remove the seat from the rear body.
2. Disconnect the battery cables as shown (Figure 21-2, Page 21-3).
3. Remove the three mounting screws (3) from the inside of the rear body (Figure 21-81, Page 21-51).
4. Pull the F&R switch case away from the front of the rear body.
5. If the wires must be disconnected from the F&R switch, label them so they will be reconnected properly.
6. Remove the F&R switch (1) by depressing the two side locking tabs and sliding the switch out of the
case (2) (Figure 21-81, Page 21-51).
Installing the Forward and Reverse (F&R) Switch
Install switch in reverse order of disassembly.

REVERSE BUZZER

Testing the Reverse Buzzer Circuit
See Test Procedure 14 - Reverse Buzzer, Page 21-33
Removing the Reverse Buzzer
See Removing the Reverse Buzzer, Page 20-30.
Installing the Reverse Buzzer
See Installing the Reverse Buzzer, Page 20-31.
Page 21-54

Hide quick links:

Advertisement

Table of Contents
loading

Table of Contents