Troubleshooting - Club Car Gasoline Service Manual

23B
E
RED WIRE
OF D.C. CORD
RED WIRE
TO RELAY
SECONDARY COIL

TROUBLESHOOTING

Use the following charts (Pages 23-34 through 23-37) as guides for troubleshooting PowerDrive System 48
vehicles. The chart (below) on pages 23-34 through 23-36 refers specifically to the on-board computer and
battery charger. The chart on pages 23-36 and 23-37 encompasses the entire vehicle electrical system. Test
procedures specified in these charts can be found on the pages immediately following the charts.
Page 23-34
PRIMARY COIL
SECONDARY COIL
DC CORD
LEADS (TAN)
BLUE WIRE
TO RELAY
SECONDARY COIL
LEADS (BLACK)
TO AMMETER
TAN WIRE TO
PRIMARY COIL
GREEN GROUND
WIRE
BLACK WIRE TO
CIRCUIT BREAKER
BLACK WIRE TO
POWER RELAY
BLUE WIRE TO
D.C. CORD
DC CORD
BLACK WIRE
FIGURE 23-23
OBC/CHARGER
WILL NOT CHARGE BATTERIES
CHECK FOR POWER
TO CHARGER OUTLET
CONTINUED ON
NEXT PAGE
TAN WIRE TO
PRIMARY COIL
RED WIRE TO HEAT SINK