Troubleshooting Guide - Club Car Gasoline Service Manual

The Charge Circuit, Continued:
20A
The on-board fuse link provides additional protection to the vehicle charging circuit. The fuse is rated for use
only with a Club Car PowerDrive charger. If it is blown, the cause should be determined before it is replaced.
E
A vehicle with a blown fuse will not charge (See Receptacle Fuse Link, Page 20-36).

TROUBLESHOOTING GUIDE

DIAGNOSTIC REFERENCE CHARTS
Use these charts as a starting point for system troubleshooting. More detailed system testing instructions fol-
low these charts.
No AC present
Restore AC
power.
Light will go
out and charge
will resume
Page 20-6
DC plug DC plug is
is connected disconnected
Light
remains on
Check function
2 on CDM
More than 75
EUs or 75% of
energy removed
from batteries
Charge ran
16 hours
Battery Warning Light
In Dash Is Glowing
Wet sense
lead fuse
Perform Test
Procedure 11
Light comes on
on page 20-20
intermittently
when vehicle
is in use and
when it is
stopped
Open circuit
(no load)
battery voltage
below 48 volts
Seal all Sense
Lead Fuse
connections.
See Test
Procedure 11,
Page 20-20
Recharge batteries
Check batteries (Section 22)
Check charger (Section 23)
Check OBC (Page 20-20)
OBC is defective
Replace OBC
FIGURE 20-4
Charge interrupt
(DC cord dis-
connected
during charge
cycle)
Glows for Light
10 seconds remains on
Batteries did
Batteries did
not receive full
not receive
charge, but
adequate
may be used
charge