Ford Electric Ranger 2001 Manual page 35

100-07-7
DIAGNOSIS AND TESTING (Continued)
• Section 303-01 Basic/Motor Transaxle
(Motor/Transaxle Lubrication System)
— Oil leak
— Low oil level
— Oil drain plug
— Halfshaft flange seal(s)
— Gear cover
• Section 303-03 Cooling System
— Cooling system leak
— Low coolant level
— Integrity of cooling system hose(s)/tube(s)
— Cooling fan
• Section 303-14 Electric Motor Management
(Traction Inverter Module Control System)
— Motor/transaxle connector (corroded)
• Section 307-05 Automatic Transaxle External
Controls (Digital Transmission Range Sensor)
— Shift cable linkage
— Shift cable alignment
— Digital transmission range (DTR) sensor
adjustment
— Transmission range selector lever
• Section 310-02 Acceleration Control
— Accelerator pedal assembly
• Section 412-02 Heating/Defrosting
(Heating/Defrosting/Ventilation)
— Climate control air filter
— Vacuum motor actuator arms
Interface Adapter Assembly (IAA) Module Diagnostic Trouble Code (DTC) Index
DTC Test Mode
U1041 Continuous
U1108 Continuous
U1110 Continuous
U1117 Continuous
U1131 Continuous
U1262 Continuous
B1238 Continuous
(Continued)
Electric Vehicle (EV) Diagnostic Direction
Description
SCP (J1850) Invalid/Missing Data for Vehicle
Speed
Invalid Data for Electronic Traction Drive
SCP (J1850) Invalid/Missing Data for Primary
ID $6E
Invalid Data for Electrical Energy Management
SCP (J1850) Invalid/Missing Data for Fuel
System
SCP (J1850) Communication Bus Fault
Over Temperature Fault
• Section 412-03 Air Conditioning
— Low refrigerant
— Refrigerant leak
— Climate control air filter
— Vacuum motor actuator arms
• Section 413-01 Instrument Cluster
— Stuck gauge(s)
— Low oil level
— Low traction battery charge
— Low coolant level
— Tripped inertia switch
— Low brake fluid level
— Parking brake set
— Charger cord plugged in
• Section 414-02 Auxiliary Battery Charging
— Auxiliary battery casing
• Section 414-03 High Voltage/Traction Battery
— Low traction battery state of charge (SOC)
— Tripped inertia switch
— High-voltage connector disconnected
— Power control station (PCS) plugged into
charger inlet
— Charger inlet
— Vehicle not in PARK during charging
— Stuck cooling/ventilation fan
Diagnostic Trouble Code (DTC) Indices
Interface Adapter Assembly (IAA) Module
Diagnostic Trouble Code (DTC) Index
No action required.
No action required.
No action required.
No action required.
No action required.
No action required.
REFER to Page 412-02-3.
100-07-7
Action
2001 Ranger EV, 01/2001