Removing And Installing Parts Of The Esp (Esc) System; Removing And Installing Sensor Unit For Esp (Esc) G419 - Skoda Octavia II 2004 Workshop Manual

8 Removing and installing parts of the
ESP (ESC) system
Remove and install sensor unit for ESP (ESC) - G419-
⇒ page 91
Removing and installing steering angle sender - G85-
⇒ page 93
8.1 Removing and installing sensor unit for
ESP (ESC) - G419-
For vehicles up to CW 21/2008:
Up to CW 21/2008 the sensor unit for ESP (ESC) -G419- (in‐
cludes: lateral acceleration sender - G200- , yaw rate sender -
G202- and longitudinal acceleration sender - G251- ) is fitted
under the right front seat.
After replacing the ESP (ESC) sensor unit -G419- , a basic setting
of the lateral acceleration sender -G200- must be performed. On
vehicles with four-wheel drive and on vehicles with HHC system,
perform the setting of the longitudinal acceleration sender as well
-G251- ⇒ Vehicle diagnostic tester.
WARNING
Strong vibrations (e.g. fall, knock) can destroy the sensor unit
for ESP (ESC) - G419- . The sensor unit for ESP (ESC) - G419-
must no longer be used.
Removing:
– Remove the right front seat ⇒ Body Work; Rep. gr. 72 .
– Remove the sill panel ⇒ Body Work; Rep. gr. 68 and lift up
the carpet.
– Unplug plug -1- from the sensor unit for ESP - G419- .
– Unscrew the two securing nuts -arrows-.
– Remove the ESP (ESC) sensor unit - G419- .
Installing:
– Installation is carried out in the reverse order.
Pay attention to the fitting position of the ESP (ESC) sensor unit
⇒ Fig. S45-0148.
When installing the ESP (ESC) sensor unit, the correct and
stress-free position on the fixture must be ensured.
Note
Never fit the ESP (ESC) sensor unit into position using fixing nuts.
– Tighten fixing nuts.
– Perform basic setting of lateral acceleration sender - G200-
⇒ Vehicle diagnostic tester. On vehicles with four-wheel drive
and on vehicles with HHC system, perform the setting of the
longitudinal acceleration sender as well -G251- ⇒ Vehicle di‐
agnostic tester
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.�
Octavia II 2004 ➤ , Octavia II 2010 ➤
Brake systems - Edition 11.2017

8. Removing and installing parts of the ESP (ESC) system

91