Master Brake Cylinder; Removing And Installing Master Brake Cylinder - Left-Hand Drive - Skoda Octavia II 2004 Workshop Manual

Octavia II 2004 ➤ , Octavia II 2010 ➤
Brake systems - Edition 11.2017
6

Master brake cylinder

Remove and install master brake cylinder - left-hand drive
⇒ page 186
Remove and install master brake cylinder - right-hand drive
⇒ page 189
6.1 Removing and installing master brake
cylinder - left-hand drive
Special tools and workshop equipment required
♦ Repair kit - 1H0 698 311 A-
♦ Brake filling and bleeding device , e. g. -VAS 5234-
Removing:
– On models fitted with a coded radio, pay attention to the cod‐
ing, determine if necessary.
– Remove battery ⇒ Electrical System; Rep. gr. 27 .
– Remove inlet connection and air filter ⇒ Engine; Rep. gr. 23
or ⇒ Engine; Rep. gr. 24 .
– Remove battery ⇒ Electrical System; Rep. gr. 27 .
Vehicles with turbocharger engines
– Disconnect the plug of the air mass meter G70.
– Remove suction hose between air filter and exhaust gas tur‐
bocharger ⇒ Engine; Rep. gr. 23 or ⇒ Engine; Rep. gr. 21 .
– Remove the connecting hose between the filler tube and the
exhaust gas turbocharger (if necessary remove the whole filler
tube) ⇒ Engine; Rep. gr. 21 .
Continued for all vehicles
– Lay sufficient non-fluffing cloths around the engine and gear‐
box.
– Extract as much brake fluid as possible from the brake fluid
reservoir.
For vehicles with manual gearbox
– Detach the return hose -B- of the clutch master cylinder from
the brake fluid reservoir and attach it slightly higher.
Continued for all vehicles
– Disconnect plug -A- from brake fluid level warning contact .
– Remove the brake fluid reservoir, to this end press the latches
at the reservoir outwards and at the same time pull the brake
fluid reservoir out of the sealing plugs.
on vehicles as of 11/2005
– Disconnect plug connection -C- from brake light switch - F- (on
vehicles with the brake light switch - F- on the master brake
cylinder).
Continued for all vehicles
186
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.�