Skoda Octavia II 2004 Workshop Manual page 63

– Unlock plug on control unit, in -direction of arrow 1-.
– Disconnect the plug from the control unit in
-direction of arrow 2-.
– Pull hydraulic unit with control unit upwards and out of the
rubber bearings. If the rubber bearings are pulled out of the
console at the same time, place the bearings in the same po‐
sition again ⇒ Item 11 (page 54)
– Unscrew the bracket from the ABS hydraulic unit.
Installing:
Note
Only remove plugs from the new hydraulic unit if the relevant
♦
brake line is installed.
If the plugs were already removed from the hydraulic unit, then
♦
brake fluid may escape and adequate filling and bleeding can
no longer be guaranteed.
– Screw the bracket onto the hydraulic unit and tighten to the
recommended tightening torque.
– Moisten the bolt of the support
cant, e.g. -D 007 000 A2- , before inserting into the rubber
bearings.
– Connect the plug to the control unit against the
-direction of arrow 2-.
– Lock the plug at the control unit, against the
-direction of arrow 1-.
– Insert the hydraulic unit with the control unit and bracket into
the rubber bearings of the console.
– Remove the plugs consecutively from the brake lines and the
ABS control unit.
– Screw the marked brake lines onto the hydraulic unit.
– Install battery tray ⇒ Electrical System; Rep. gr. 27 .
– Install inlet connection and air filter ⇒ Engine; Rep. gr. 23 or
⇒ Engine; Rep. gr. 24 .
– Install battery ⇒ Electrical System; Rep. gr. 27 .
Note
If the battery earth strap is disconnected and connected, carry out
certain additional operations ⇒ Electrical System; Rep. gr. 27 .
– Position engine cover.
– Remove brake pedal load e.g. -V.A.G 1869/2- .
– Bleed brake system
– Code the control unit - J104- ⇒ Vehicle diagnostic tester.
.
⇒ Item 9 (page 54)
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.�
⇒ page 168 .
Octavia II 2004 ➤ , Octavia II 2010 ➤
Brake systems - Edition 11.2017
with lubri‐
57