Repairing Rear Brake; Changing The Brake Pads Of The Rear Brake - Mounting Instructions - Skoda Octavia II 2004 Workshop Manual

2

Repairing rear brake

Changing the brake pads of the rear brake - Mounting instructions

⇒ page 111
Repairing rear brake CII 41 (vehicles with front and four-wheel
drive) ⇒ page 112
Removing and installing brake pads CII 41
Removing and installing brake pad CII 41
Repairing rear brake CI 38 (vehicles with front-wheel drive)
⇒ page 119
Removing and installing brake pads CI 38
Removing and installing brake caliper CI 38
Repairing rear brake Bosch BIRIII (vehicles with front and four-
wheel drive) ⇒ page 125
Removing and installing brake pads Bosch BIRIII
Removing and installing brake caliper Bosch BIRIII
2.1 Changing the brake pads of the rear
brake - Mounting instructions
When changing the pads, pay attention to the following points:
– Check protective collar of brake calliper piston.
Replace protective cap if damaged.
When replacing the protective cap:
– Check the contact surfaces of the brake piston and the brake
caliper for any dirt (oxidation).
Carefully clean the piston as well as the brake caliper if dirty and
replace the sealing cap.
– Check the brake piston and the brake caliper (corrosion,
grooves on the outside of the cylinder surface), replace the
brake caliper completely if damaged.
For brake caliper piston, press into the initial position:
– Check if the piston can be slightly pressed into the brake cal‐
iper.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
If the piston cannot be slightly pressed into the brake caliper:
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.�
– Check and clean the brake piston as well as the brake caliper,
replace sealing sleeve and protective cap.
Replace the brake caliper completely if damaged.
Octavia II 2004 ➤ , Octavia II 2010 ➤
⇒ page 114
⇒ page 117
⇒ page 120
⇒ page 123
⇒ page 126
⇒ page 130
Brake systems - Edition 11.2017
2. Repairing rear brake
111