Skoda Octavia II 2004 Workshop Manual page 50

Octavia II 2004 ➤ , Octavia II 2010 ➤
Brake systems - Edition 11.2017
13 - Gasket
❑ for brake servo
14 - Sealing grommet
❑ for the connection of the vaccum hose
15 - Brake servo
❑ on petrol engines, the required negative pressure is drawn from the intake manifold or it is generated
with a vacuum pump
❑ vehicles using a diesel engine are fitted with a vacuum pump for generating a low pressure
⇒ page 178
❑ Inspect proper operation:
– With the engine off press down brake pedal repeatedly with force (this reduces the pressure already
present in the device).
– Now step on and hold brake pedal with medium pressure and start engine. If the brake servo is functioning
properly, the brake pedal will be felt to go down as the servo takes effect.
❑ if there are faults replace completely
❑ Summary of components
❑ Removing and installing
16 - Sealing ring
17 - Master brake cylinder
❑ cannot be repaired, replace completely in the event of faults
❑ Summary of components
❑ Removing and installing
18 - The brake light switch - F- and brake pedal switch - F47-
❑ installed from 11/05
❑ Fitting location: on master brake cylinder
❑ Removing and installing
❑ Check ⇒ Vehicle diagnostic tester
19 - Screw, 5 Nm
20 - Protection plate
21 - Nut, 25 Nm
❑ replace after each removal
22 - Sealing grommets
❑ moisten with brake fluid and press in brake fluid reservoir
23 - Brake fluid reservoir
24 - Screw cap
25 - Heat protection plate
26 - Self-locking nut, 8 Nm
27 - Self-locking nut; 20 Nm
28 - Console
29 - Screw, 8 Nm
30 - Mounting bracket
– Moisten the bolt of the support with lubricant, e.g. -D 007 000 A2- , before inserting into the rubber
bearings
❑ after installing, check for firm seating
44
Rep. gr.45 - Anti-lock brake system
⇒ page 178
⇒ page 173
⇒ page 192
⇒ page 173
⇒ page 186
⇒ page 149
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.�