Fuel Lines; Fuel Filter; Fuel Pump; Carburetor - Club Car Carryall 295 2014 Maintenance And Service Manual

GASOLINE ENGINE, MUFFLER, FUEL SYSTEM,
AND CLUTCHES

FUEL LINES

See General Warnings, Section 1, Page 1-2.
The fuel lines must be properly routed and all hose clamps must be tight (Figure 15-5, Page 15-8). The fuel lines
should be kept clean. See following NOTE and WARNING.
NOTE: Use only hoses with SAE J30R7 rating to replace the fuel lines.
WARNING
• Make sure fuel lines are the correct length and are properly routed. Failure to heed this warning
could result in damage to the fuel lines and fire.

FUEL FILTER

See General Warnings, Section 1, Page 1-2.
One in-line filter (6) is installed between the fuel tank and the fuel pump (Figure 15-5, Page 15-8). Fuel filters, fuel
lines, and the fuel tank vent should be inspected periodically for leaks and replaced when necessary. Filter changes
should not exceed the recommended interval. See Periodic Service Schedule on page 10-1. Replace the fuel filter
as instructed. See the Kawasaki FH680D engine manual (CC P/N 103351201).

FUEL PUMP

See General Warnings, Section 1, Page 1-2.
Procedures for inspection, removal, and installation can be found in the engine manual. See the Kawasaki FH680D
engine manual (CC P/N 103351201).

CARBURETOR

See General Warnings, Section 1, Page 1-2.
WARNING
• The carburetor is equipped with an electric heater and must be grounded to the engine in order to
prevent the risk of a spark. Always have a ground wire properly installed.
Before suspecting the carburetor as the cause of poor engine performance, make sure the fuel and ignition systems
are in proper operating condition. Check the following items:
• Spark plug and gap condition. See the Kawasaki FH680D engine manual (CC P/N 103351201).
• Air filter element. See Air Filter Replacement on page 15-26.
• Fuel filters. See Fuel Filter on page 15-9.
• Choke and air intake system (for restriction of air flow). See Air Intake System on page 15-26.
• Fuel pump. See the Kawasaki FH680D engine manual (CC P/N 103351201).
• Fuel lines (from fuel tank to filter to pump to carburetor). See Fuel Lines on page 15-9.
• Exhaust system (for restrictions).
If the carburetor has failed, replace it. See the Kawasaki FH680D engine manual (CC P/N 103351201).
2014 Carryall 295/XRT 1550 Maintenance and Service Manual
15
Fuel System
Page 15-9