Suzuki Wagon R Manual page 3956

(Z10XEP AND Z12XEP ENGINES)
WARNING:
For vehicles equipped with a Supplemental Restraint (Air Bag) System:
• Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to "System Components and Wiring Location View and Connec-
tions" under "General Description" in Section 10B in order to confirm whether you are performing
service on or near the air bag system components or wiring. Please observe all WARNINGS and
"Service Precautions" under "On-Vehicle Service" in Section 10B before performing service on or
around the air bag system components or wiring. Failure to follow WARNINGS could result in unin-
tentional activation of the system or could render the system inoperative. Either of these two condi-
tions may result in severe injury.
• Technical service work must be started at least 90 seconds after the ignition switch is turned to the
"LOCK" position and the negative cable is disconnected from the battery. Otherwise, the system
may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
General Description ..................................... 6G4-2
Cranking System Circuit Diagram .............. 6G4-2
Diagnosis ...................................................... 6G4-2
Cranking System Symptom Diagnosis ....... 6G4-2
Cranking System Test ................................ 6G4-4
Pull-in test............................................... 6G4-4
Hold-in test ............................................. 6G4-4
SECTION 6G4
CRANKING SYSTEM
CONTENTS
ON-Vehicle Service .......................................6G4-6
Tightening Torque Specification .................6G4-6
CRANKING SYSTEM (Z10XEP AND Z12XEP ENGINES) 6G4-1
Plunger and pinion return test .................6G4-4
No-load performance test........................6G4-5
Starting Motor Removal and Installation .....6G4-6
Removal ..................................................6G4-6
Installation ...............................................6G4-6
6-3
6A3
6B3
6C3
6G4
6K3
6K3